What Causes Shackle Straps To Flip Below the Equalizer
Question:
Is there a certain reason to have the shackles above the equalizer the current setup on my trailer has them below
asked by: Just
Expert Reply:
It is not uncommon for the shackle straps to flip once weight is lifted off the suspension but if they do so when you have a load bearing then this will not allow for proper load distribution or suspension travel. The cause of this issue is that the leaf springs are too long, the shack straps are too long, or a combination of both. The best option for you to make sure you get the proper spacing would be to change these parts out. If you can let me know the distance between your leaf spring hangers on center I will see if we have a better leaf spring and shackle strap combo for you otherwise you could replace this all using the Tandem-Axle Trailer Hanger Kit part # APT5 with the 5-Leaf Double-Eye Spring part # e34SR.
Products Referenced in This Question
5-Leaf Double-Eye Spring for 6,000-lb Trailer Axles - 25-1/4" Long
- Trailer Leaf Springs
- Double Eye Springs
- 6000 lbs
- 1-3/4 Inch Wide
- 5 Leaf
- 25-1/4 Inch Long
- Painted
- etrailer
more information >
Product Page this Question was Asked From
Tandem-Axle Trailer Hanger Kit for Double Eye Springs - 3-1/4" Tall Front/Center/Rear
- Trailer Leaf Spring Suspension
- Hangers
- Suspension Kits
- Boat Trailer
- Camper
- Car Hauler
- Snowmobile Trailer
- Utility Trailer
- Double Eye Springs
- Tandem Axle
- etrailer
more information >
Continue Researching
- Shop: Grease Seal - Double Lip - ID 1.719" / OD 2.565" - for 3,500-lb Axles - Qty 2
- Shop: Tandem-Axle Trailer Hanger Kit for Double Eye Springs - 3-1/4" Tall Front/Center/Rear
- Shop: Tandem-Axle Trailer Hanger Kit for Double-Eye Springs - 2-1/2" Front/Rear, 4-1/2" Center
- Shop: Nylon Bushing - 9/16" Inner Diameter, 11/16" Outer Diameter - 1-3/4" Long
- Shop: Suspension Kit for Tandem-Axle Trailers - 1-3/4" Wide Double Eye Springs - 2-1/4" Links
- Shop: Curved Equalizer for 1-3/4" Double Eye Spring - 7-3/4" Long - 9/16" Hole
- Shop: Curved Equalizer for 1-3/4" Wide Double-Eye Springs - 6-1/8" Long - 9/16" Center Hole
- Article: Double-Eye Trailer Suspension System Review
- Search Results: 10~60 seal
- Q&A: Comparing the eTrailer and Dexter Electric Trailer Brake Kits
- Search Results: grease cap
- Q&A: Replacement Springs and Cushioned Equalizers 2023 Jayco Featherlite
- Video: etrailer Trailer Suspension - Leaf Spring Suspension - AP233 Review
- Video: etrailer Trailer Bearings Races Seals Caps - Bearings - L44643 Review
- Video: Redline Unitized Oil Seal for Trailer Hubs Installation
- Shop: Gooseneck Hitch
- Q&A: Comparing Trailer Tire Sizes 16.5x6.5-8 and 165/65-8
- Search Results: 16.5x6.5 8
- Search Results: submersible led trailer light kit
- Search Results: trailer safety chains
- Q&A: Determining Correct Replacement Equalizers and Shackle Straps for Older Trailer
- Video: Review of Lippert Trailer Leaf Spring Suspension - Axle Mounting Hardware - LC52SV
- Video: Lippert Tandem Axle Road Armor Wet Bolts and Shackles Kit Review
- Q&A: How to Determine the Right Replacement Equalizer for a Horse Trailer
- Q&A: Weld On Versus Bolt On Hitch Receiver for Use with Bike Racks and Cargo Carriers on RVs
- Search Results: road armor
- Q&A: Replacement Leaf Springs and Equalizers for 2006 Mega Lite Extreme LT19 Travel Trailer
- Search Results: 25 1 4 leaf spring
- Shop: Tonneau Cover
- Video: Review of SuperSprings Trailer Leaf Spring Suspension - Springs - SS26MV