Troubleshooting Titan BrakeRite EHB with Leak from a Weep Hole

Question

Question:

I have a Titan EHB brake controller No T4813100. It is leaking from a weep ho.e and I have to keep adding fluid. Can you tell me wher to send the unit for repair.

asked by: Paul W

0

Expert Reply:

For your Titan BrakeRite I Plug and Play Electric-Hydraulic Actuator Kit # T4813100, the only replacement part we carry is the Replacement Master Cylinder Cap for Titan BrakeRite Brake Actuators # T4830600. If the cap is the weep hole you are referring to, it may simply need a replacement cap. If that doesn't solve your problem, then I recommend sending it for repair.

To replace the whole unit, I recommend the Titan BrakeRite I Plug and Play Electric-Hydraulic Actuator Kit # T4813102.

expert reply by: Jason S

0

Answer 1

The Master Cylinder Filler Cap #T4480701 on your Titan Aero 6000 brake actuator does have a small pin hole that works with the diaphragm in the cap to release excess pressure in the reservoir. It may be that either fluid is leaking from this hole in…

view full answer...

Answer 2

I was unable to find a reference to part 4814400 so I assume you were referring to the Titan BrakeRite Electric-Hydraulic Actuator #T4813102 . I contacted Titan who told me it was possible it burned the pump if it ran for a time and you should look…

view full answer...

Answer 3

The Titan 60ZX7000 brake actuator is a Model 60 actuator, and you do have the correct part for a replacement master cylinder: - Replacement Master Cylinder Assembly for Titan Model 60 and Aero 7500 Brake Actuators - Drum #T4395100 So this will work…

view full answer...

Answer 4

According to Titan, if only the white and black wires are connected, the hydraulic pump should not run. With those two wires attached, the pump should start when the blue wire is touched to the positive battery terminal. The folks at Titan tell me…

view full answer...

Answer 5

I would recommend using a spray lubricant like WD-40 to try and loosen the cap on the master cylinder of your coupler actuator. Using a tool like vise-grips should allow you to remove the cap from the housing. If you are able to remove the cap and…

view full answer...

Answer 6

Locking out a Titan Model 60 actuator like the part #T63FR that you referenced requires inserting the lock out tool into the into the slot right behind the portion of the coupler that inserts into the outer casing. I pointed out where in the attached…

view full answer...

Answer 7

The reason your reservoir is empty on your Titan Zinc-Plated Brake Actuator #T43397007K is likely due to a leak somewhere in the brake lines, calipers, or master cylinder. You're going to want to check the undercarriage of your vehicle for leaks…

view full answer...

Answer 8

We prefer the Hydrastar Actuator part #HBA16 as it is the most reliable and works the best. Rarely do we ever get emails or calls for help troubleshooting problems with this actuator and is the one our installers like the most so I would recommend it…

view full answer...

Answer 9

The Titan BrakeRite EHB Electric-Hydraulic Actuator for Disc Brakes part #T4813100 will need to receive power from a 12 volt battery with a 40 amp circuit breaker like part #9510 placed 6" from the positive battery terminal. I have attached a…

view full answer...

Answer 10

There are a couple of ways you can bleed a trailer brake system. Titan offers the following instructions, which I have also linked for you, on bleeding the brakes: Remove the master cylinder cap and fill the reservoir to three quarters full with…

view full answer...

Answer 11

Your Titan Aero 6000 will use master cylinder cap #T4480701. There are a few different caps used on various Titan actuators but yours does use this one.

view full answer...

Answer 12

That looks like an older Atwood coupler. Which I am not surprised it isn't working as it's the most problematic actuator that we have experience with. Most popular coupler we have that would work as a replacement would be the Titan actuator…

view full answer...

Troubleshooting Titan BrakeRite EHB with Leak from a Weep Hole

Products Referenced in This Question

Product Page this Question was Asked From

Featured Help Information

Miscellaneous Media

Continue Researching