Availability of Guide-On Bunk Bracket Kit

Question

Question:

Hi, I want to install a bunk style guide on and looking at the CE Smith System for 60 long sides. My problem is I need side boards longer than 60. Can I purchase just the metal braketts and hardware and not the carpet covered wood bunks? Thanks!

asked by: Chuck S

0

Expert Reply:

The CE Smith Bunk Board Guide-On Kit, part # CE27600K75 includes everything necessary to install bunks up to 12 feet long, including the 70° posts, carpet, brackets and mounting hardware. The mounting hardware is compatible with frame members up to 3 inches wide by 4-1/2 inches tall. For 90° posts, use # CE27600K90.

expert reply by: Mike L

0

Answer 1

Since the outside frame channel on your trailer is about as wide as your boat you'd need to go with a guide on that has a 90 degree angle for the upright posts instead like the part #CE27600K90 so that you'll get closer contact like you…

view full answer...

Answer 2

The CE Smith Bunk-Style Guide-Ons for Boat Trailers part #CE27600 can be used on any trailer but traditionally they are not used on pontoons. Not saying we do not install them on pontoons. As a matter of fact we used the CE Smith Bunk-Style Guide-Ons…

view full answer...

Answer 3

Yes, the CE Smith Bunk-Style Guide-Ons for Boat Trailers - 60" Long - 1 Pair #CE27600 can work on the inside of a pontoon boat. Based on the photo you may prefer the CE Smith 90-Degree Bunk Board Guide-On Kit #CE27600K90 which will includes…

view full answer...

Answer 4

A spacing of 1-inch between the boat's hull and the surface of the carpeted bunks is usually best. This allows enough wiggle room for loading the boat while keeping it in a reasonably snug fit in the bunks. The CE Smith Bunkboard Guide-On Kit…

view full answer...

Answer 5

In order to determine the torque rating for the lug nuts on your trailer you will need to know check out the chart I attached that shows all of the torque specs for all the trailer lugs available based on stud size, wheel material and wheel size.

view full answer...

Answer 6

The difference between an load range C and load range D tire in the same size is the capacity and psi rating. The two tires will still have the same dimensions and fit on the same wheel. The D rated tire has a higher capacity. For a ST175/80D13 like…

view full answer...

Answer 7

Load range B trailer tires are going to have a lower capacity than C load range tires. Basically that, psi rating, and the ply rating are the only differences. A higher load range tire would last a little longer than lower load ranges of the same…

view full answer...

Answer 8

To determine the size of the hub assembly you need to purchase you have to determine which bearings are in the old assembly. If the old assembly has L44649 inner bearings, you would use the hub you chose #8-258-5UC1. If the inner bearings are marked…

view full answer...

Answer 9

A BT8 spindle would have a diameter of .99 of an inch where the bearings would both install and would have a diameter of 1.24 where the great seal would ride. That would require a hub part #AKIHUB-440-2-1K for an idler hub. A BTR spindle would have…

view full answer...

Answer 10

Hey Richard, thanks for reaching out! The Dexter DX7.5 Drop-N-Go Brake Actuator #099-175-00 is a great option for a replacement actuator because it's a direct replacement for the common Model 60 actuators that were popular in the '90s.…

view full answer...

Answer 11

The manual lockout on your Atwood 85778 surge brake coupler is there so that you can back up the trailer without the brakes locking up on you. Yes you can safely tow your trailer with the broken manual lockout, you just have to make sure you…

view full answer...

Answer 12

To find the load capacity for your axle you should look on the trailer VIN plate or sticker that lists the VIN number. The weight rating of the axle should be listed on that same plate or sticker. Also, the axle could have a tag or plate on it that…

view full answer...

Availability of Guide-On Bunk Bracket Kit

Products Referenced in This Question

Product Page this Question was Asked From

Continue Researching