Recommended Ways To Raise Height Of Small 4 X 8 utility Trailer

Question

Question:

I have a Teske utility trailer 4X8foot with wooden sides VIN 5ERTM0810FM084538 with 12 inch wheels. I would like to lift the trailer 3 inches and put 14 inch wheels on to increase rear clearance when I lift and move the trailer by hand. The tongue does not extend high enough because the rear hits the ground and strains my back. Would shackles work? Since the rear of the leaf spring are not bolted down I suspect shackles on the front of the leaf spring would not work. Shackles seem easier than over under install. Thanks for your help

asked by: Mark A

1

Helpful Expert Reply:

Since you do not want to use an over/under kit on your axle, the best way to raise the trailer would be to use longer hangers for the leaf springs.

You may be able to use a hanger like part # E4139. This hanger is designed for double-eye springs and is 4-1/4 inches tall. The old hangers will need to be cut off and the replacement hangers welded on by a professional. I have attached a link to our product page for the trailer hangers we offer you can check out.

If your axle measures 2-3/8 inches diameter you can use an over-under kit like part # K71-384-00. For a 3-inch axle the over-under kit is part # K71-385-00. The spring seats will need to be welded in place by a professional because you cannot just flip an axle. Axles have a slight bow and if flipped could cause issues with tire wear and trailer handling.

When you decide to replace the wheels make sure you choose the tire/wheel combo that will have enough clearance and has the right bolt pattern for your hubs.

expert reply by: Jeffrey L

1

Answer 1

I do have an option for you but the Stromberg Carlson 4000 Series 5th Wheel Louvered Tailgate part #VGD-10-4000 does not have a spot for the factory backup camera. Therefore you would either need to find a way to mount this yourself, go without, or…

view full answer...

Answer 2

Most manufacturers are in the process of discontinuing their fifth wheel tailgates with the camera relocation kits due to mechanical issues. Therefore I could not find one that fits your 2017 Ford F-350 Super Duty. The Stromberg Carlson 4000 Series…

view full answer...

Answer 3

The Dexter Torflex Lift Kit #K71-707-02 referenced in your question is designed for the #10 Torflex axle with a 2,300 to 4,000 pound capacity. As you mentioned, the lift kit cannot be used with Torflex axles that use a 3 inch high profile bracket.…

view full answer...

Answer 4

Based on my research, the Trailer Hub and Drum Assembly - 8,000-lb E-Z Lube Axles #AKHD-865-8-EZ-K will be a replacement for the 90865 Rockwell hub and drum. Both of these hub and drum assemblies are 12-1/4" diameter, have an 8,000 lb capacity,…

view full answer...

Answer 5

There is no set angle, but you want to leave enough room for the suspension to articulate. By looking at the photo, you will indeed need to move the rear hanger back a bit. The shackle strap be much closer to vertical, as shown in the diagram…

view full answer...

Answer 6

I do have all of the components you will need to flip the axle on your tent trailer but there is not an all inclusive kit per se to do so. However, the kits are pretty basic as all they include are u-bolts, tie plates, and spring seats. For your…

view full answer...

Answer 7

Well shackle length is mainly based on the height difference between the front and rear hangers. The rear hanger normally doesn't hang as low as the front so that the shackle can offset the difference and add the ability to move. What is the…

view full answer...

Answer 8

When replacing shackle straps they should be the same length as the ones that were previously on your tandem axle trailer; replacing them with longer straps will result in additional play in your trailer suspension which could lead to additional wear…

view full answer...

Answer 9

I do have an option but Glo-Brite is no longer in business so you won't be able to get any replacement parts for these lights such as lenses. The only option you have would be a full replacement for which the most similar option we offer is the…

view full answer...

Answer 10

The first thing I would check on your trailer is the capacity of the springs. You need to be sure the spring capacity is rated at 1/2 the axle capacity. That way 2 springs equal the capacity of the trailer axle for proper fit. Check the arch of the…

view full answer...

Answer 11

For your Dometic Duo-Therm 57915.622 I recommend checking out the: -Advent Air RV Air Conditioner #ACM135. This is a direct replacement for your current unit, has a 13.5K Btu per hour heating capacity, and will plug into your existing thermostat.

view full answer...

Recommended Ways To Raise Height Of Small 4 X 8 utility Trailer

Products Referenced in This Question

Product Page this Question was Asked From

Featured Help Information

Instructions

Miscellaneous Media

Continue Researching