Screws On Awning Rail Keep Coming Out
Question:
I have a 2019 5th wheel that had slide out awning installed and now I see the screws the attach the rail to the side of the camper are coming out from front of trailer to the rear. The rails were installed without the butal tape. I have tried to retighten the screws but they don’t tighten up. I am thinking of using larger screws or rivets after I get the tape and install it. What are your recommendations for correcting this problem? Thanks
asked by: Dan K
Helpful Expert Reply:
In regards to installing an awning rail, you do indeed need butyl tape between the rail and camper. I recommend the Alpha Systems Q180 Butyl Tape part # AL92FJ for rails up to 30'. If the old screws are coming out then I recommend a longer screw if the trailer permits for this. If not, you'll have to secure the awning rail in new screw holes and fill the old with silicone. I recommend the TremPro 644 Silicone Sealant part # 0160297.
Products Referenced in This Question
TremPro 644 Silicone Sealant - 10.1-Fl-Oz Cartridge - White
- Lubricants Sealants Adhesives
- Sealant
- Multi-Purpose Sealant
- 10.1 oz
- Flint Hill Goods
more information >
Product Page this Question was Asked From
Solera RV Slide-Out Awning - 85" Wide - Black
- RV Awnings
- Slide-Out Awnings
- Extends 48 Inches
- 80 Inch Wide
- 81 Inch Wide
- 82 Inch Wide
- 83 Inch Wide
- 84 Inch Wide
- 85 Inch Wide
- Black
- Lippert
more information >
Featured Help Information
Instructions
Continue Researching
- Shop: Rubber Trim for RVs, Boats, and Utility Vehicle Trim Molding - 25' Long x 7/8" Tall
- Shop: Solera RV Slide-Out Awning - 85" Wide - Black
- Q&A: What is the Awning Rail that Slide Toppers Attach To
- Shop: RV Awning Locking Pins - Qty 2
- Q&A: Replacement Clearance Lights Needed for GLO-BRITE 122R and 122Y Lights
- Shop: LED Trailer Clearance or Side Marker Light with Reflex Reflector - 2 Diodes - Amber Lens
- Shop: LED Trailer Clearance or Side Marker Light with Reflex Reflector - 2 Diodes - Red Lens
- Shop: Replacement 17'1" Fabric for 18' RV Awning - Universal - Solid Black
- Q&A: How Can The Access Plate For The Solera RV Slide-Out Awning Be Installed?
- Q&A: Does Solera RV Slide Out Awning Need Clearance Above Awning Rail
- Shop: Butyl Tape for Enclosed Trailer - 1" Wide x 1/8" Thick - (1) 50' Roll
- Shop: RV Roof Membrane
- Q&A: Replacement Tail Light Lens for 1992 Coleman Pop-Up Camper
- Q&A: Wiring a Camper Shell Third Brake Light on a 2017 Chevrolet Silverado
- Shop: Trailer Hitch
- Video: Lippert Solera Slider Slide-Topper Review
- Article: Trailer Wiring Diagrams
- Search Results: 44649
- Video: The Club Utility Lock Review
- Search Results: 68149
- Article: How to Choose the Right Trailer Hitch Class
- Shop: Trailer Wiring
- Q&A: How to Add Tension to Solera Slide-Topper
- Article: Brake Controller 7- and 4-Way Installation Kit (ETBC7)
- Search Results: 25580
- Shop: Fifth Wheel Hitch
- Video: Roadmaster Automatic Battery Disconnect Installation - 2020 GMC Sierra 1500
- Search Results: dust caps
- Shop: Brake Controller
- Article: Trailer Tire Sizing