Troubleshooting Cluncking Sound on Demco Hijacker

Question

Question:

Me demco makes a loud violent clunk on take off and stops how can this be corrected?

asked by: Charles M

0

Expert Reply:

The capture plates may not be adjusted properly ensure they are even on each side and all parts lubricated. If you have an older hitch that may be worn this should be addressed. I suggest you check all bolts on the pin box as well.

expert reply by: Michael R

0

Answer 1

The Demco Hijacker Autoslide 5th Wheel Hitch part #DM8550038 is an excellent option for a 2019 Ford F-350 with factory prep package (which you have). It has a set of four locking attachments on the side plates which will line up with the pucks in the…

view full answer...

Answer 2

How old is the hitch? Does your fifth wheel have a standard pin box or a cushioned pin box? Has it been lubricated? Does the locking bar automatically lock when the jaw closes? The thing that comes to mind immediately is the capture plates may not be…

view full answer...

Answer 3

It sounds to me like the gears of the slider inside of your Replacement Head and Base Assembly for Demco Hijacker Autoslide 5th Wheel Trailer Hitches #DM6077 may either have debris blocking them, the teeth may be chewed up and need to be replaced, or…

view full answer...

Answer 4

You will have to go with a sliding hitch to allow the trailer to make tight turns. For a trailer 8 feet wide the only bed length that's going to allow 90 degree turns without a slider is a stationary hitch. That being said you have two options.…

view full answer...

Answer 5

The OEM prep package consists of 4 "pucks" in the bed of the truck that will allow you to drop in puck style hitches for easy installation and removal, that gives you a completely clear bed when not in use. The B&W Companion OEM 5th…

view full answer...

Answer 6

For sag from towing a trailer the best recommendation I can make is actually a weight distribution system. Suspension enhancement will help level your truck while towing. But the advantage to a weight distribution system is that it levels the vehicle…

view full answer...

Answer 7

It sounds like the purpose of getting the air helper spring would be to counteract the 1 inch compression you're getting in your rear suspension caused by the pin weight of your 5th wheel. If that's the case, I believe that the AirLift 5000…

view full answer...

Answer 8

There's not many differences between the Air Lift WirelessONE item #AL25980EZ and item #AL25980. The main difference is that the item #AL25980EZ has a slightly higher CFM at 1.03 compared to 0.92 and it runs slightly more efficient at 9% over 15%…

view full answer...

Answer 9

The Air Lift WirelessONE Compressor System #AL25980EZ and Air Lift WirelessONE Compressor System #AL25980 are nearly identical with only some very minor differences in CFM and duty cycle ratings. The #AL25980EZ will also come with an easier mounting…

view full answer...

Answer 10

There are a number of differences between the Firestone Ride-Rite Air Helper Springs #F2445 and Air Lift LoadLifter 5000 Ultimate Air Helper Springs #AL88299, starting with fit. While the Air Lift will fit all models of the 2018 Toyota Tundra, the…

view full answer...

Answer 11

The best air bag kit for your 2022 Ford F-350 that has a single rear wheel axle is the part #F95FV which has the 5,000 lb capacity you are wanting. Firestone bags are superior Air Lift bags. The ply rating of the rubber is higher, the attachment to…

view full answer...

Answer 12

I recommend going with the Air Lift LoadLifter 7500 XL Ultimate Air Helper Springs #AL89DQ for hauling around an in-bed camper with your 2024 Ford F-350 Super Duty. I really like this kit because it has the higher 7,500 lb rating (which you don't…

view full answer...

Troubleshooting Cluncking Sound on Demco Hijacker

Product Page this Question was Asked From

Featured Help Information

Instructions

Continue Researching