How to Determine Wire Functions of Vehicle 7-Way

Question

Question:

I have a seven pin plug and only have 6 wires. My colors are Brown, yellow, white, black, green, red Can you please send me a diagram of how to place them in the plug.

asked by: Pam D

0

Expert Reply:

To determine how to wire any connector you will need to determine the function of each wire with a circuit tester as there is no universal color code. I recommend the very handy Cordless Circuit Tester # PTW2979 due to how easy it is to use.

Once you find their functions you can match them to your 7-way, and the accompanying diagram shows the connections for the different style of 7-ways.

I have added a link to a help article on trailer wiring I very strongly recommend reading.

expert reply by: Kyle S

0

click to enlarge

Answer 1

Only the blue wire is ran to the trailer brake connection at the rear of the vehicle. This wire should be 10 gauge. The ground for the brake controller is ran to the negative battery post or a suitable ground point on the vehicle. The grounds for the…

view full answer...

Answer 2

It sounds like either his truck isn't wired correctly or your truck and trailer aren't wired correctly. This can be easily determined by using a circuit tester like part #PTW2979 to test the various functions. On a typical 4-Way the one pin…

view full answer...

Answer 3

Even though there are some generic wire colors for certain functions there isn't really a rule saying that those colors have to be used. The result is that any color can be used for any function which can get confusing. The best way to make sure…

view full answer...

Answer 4

It sounds like your brake pin has constant 12V power and it should not. You will need a circuit tester, such as the Cordless Circuit Tester, part #PTW2979, so you can check the voltage on the brake output pin on your 7-way connector. This pin should…

view full answer...

Answer 5

The brake wire on a trailer is typically blue but this can certainly vary as trailer manufacturers tend to change up the colors they use at the factory and a previous owner may have also re-wired it using different color wiring. This is why it is…

view full answer...

Answer 6

The interesting thing about 6-ways is that there are two different ways they can be wired with the difference being the brake output circuit and 12v power circuit being swapped. I recommend testing the center pin and the 10:00 pin with a Circuit…

view full answer...

Answer 7

The difference between the Class II and Class III hitches has to do with their Gross Trailer Weight (GTW), their Tongue Weight (TW), and their Hitch Receiver Size. Class II trailer hitch receivers have a 1-1/4 inch receiver and can be rated up to…

view full answer...

Answer 8

A 4-Way trailer connector has the basic lighting functions only; running lights, left turn signal and brake lights, right turn signal and brake lights, and ground. A 7-Way has these functions and a 12 volt circuit, a circuit for electric trailer…

view full answer...

Answer 9

Hey HPA, I would go with the Air Lift kit part #AL64VJ that fits your 2019 Toyota RAV4 based on what you described and your needs. This gives you adjustable support that you can tailor as needed so that you get the exact amount of support you need…

view full answer...

Answer 10

It could be a tow package fuse on the vehicle. Use the owners manual to find the locations of fuses/relays related to the tow package wiring to check them and replace as needed. If the issue is not a fuse or relay then you can test the vehicle side…

view full answer...

Answer 11

I would be happy to confirm the parts you referenced fit your 2019 Chevy Colorado and are compatible together. I have listed them below, along with any changes, and attached installation videos. Roadmaster Nighthawk All Terrain, Non-Binding Tow Bar…

view full answer...

Answer 12

Normally trailer coupler height is around 17 inches, from the ground to the bottom of the coupler, and most hitch manufacturers design their hitches to work with a ball mount that will end up very close to this measurement. I am including a link to…

view full answer...