Why Would Prodigy Brake Controller Show Random Numbers Occasionally With No Trailer Connected
Question:
Our prodigy controller will periodically show numbers in the display even though our trailer is not hooked up. Sometimes it seems to work ok, 2 little blue dots and nc when you turn the engine off. Other times the minute you start the vehicle, numbers appear in the display and they go up and down depending on how hard you are applying the brakes. The trailer dealership that put the system on our vehicle has tried to remedy the problem and we had the vehicle to the Chevy dealer to have them check the wiring. Can you help?
asked by: Christine J
Expert Reply:
Somehow a 12 volt power source is shorting out to the red wire of the brake controller. This is the circuit that tells the controller to turn on and start looking for braking so an intermittent short here is going to cause the controller to show numbers on the display when you hit a bump. Try checking the wiring of the controller to see if you can separate out the red wire better from the other wires and the problem should go away.
Product Page this Question was Asked From
Tekonsha Prodigy P2 Trailer Brake Controller - 1 to 4 Axles - Proportional
- Trailer Brake Controller
- Proportional Controller
- Electric
- Electric over Hydraulic
- Automatic Leveling
- Under-Dash Box
- Dash Mount
- Up to 4 Axles
- LED Display
- Up to 360 Degrees
- Tekonsha
more information >
Featured Help Information
Instructions
Miscellaneous Media
Continue Researching
- Shop: Demco Channel Tongue Trailer Coupler - eZ-Latch - Zinc - 2" Ball - Bolt On - 7,000 lbs
- Shop: Replacement Dexter Bolt-On Shock Kit for 2-3/8" or 3" Diameter Axle - Single Axle
- Shop: Lippert Bolt-On Shock Kit w/ Heavy Duty Gas Shocks - 5,200-lb to 7,000-lb (3") Overslung Axle
- Shop: Lippert Bolt-On Shock Kit w/ Heavy Duty Gas Shocks - 3,500-lb (2-3/8") Axle
- Shop: Lippert Standard Replacement Shock - Black
- Q&A: How do I Tell if the Brake Controller is Bad
- Shop: Lock N Roll Articulating Hitch for 2" Receivers - 2-1/2" Drop/Rise - Vehicle Side - 11K
- Shop: MORryde Rubber Equalizers for Tandem Axle Trailers - 33" Wheelbase - 8K
- Q&A: Lug Nut Torque Chart for Trailer Wheels
- Search Results: leaf spring
- Article: Trailer Wiring Diagrams
- Shop: Suspension Enhancement
- Q&A: Front Mounted Hitch Receiver for 2007 Dodge Ram 2500
- Search Results: equalizer
- Video: Timbren Axle-Less Trailer Suspension System Installation
- Shop: Trailer Hitch
- Article: Double-Eye Trailer Suspension System Review
- Shop: Trailer Wiring
- Search Results: safety chains
- Q&A: How to Wire Electric Brakes on a Tandem Axle Trailer
- Video: Gooseneck Trailer Hitch Installation - 2004 Dodge Ram Pickup
- Article: How to Raise Your Travel Trailer Height
- Q&A: Does Truck with 6-1/2 ft bed Have to Use Slider Hitch for Turning Clearance with Fifth Wheel Hitch
- Shop: Gooseneck Hitch
- Article: How to Accurately Measure Trailer Leaf Springs
- Search Results: trailer lights
- Search Results: timbren
- Article: Wiring Trailer Lights with a 7-Way Plug (It's Easier Than You Think)
- Video: Gooseneck Trailer Hitch Installation - 2006 Dodge Ram Pickup
- Q&A: Differences Between Curt C31017 and Draw-Tite 65046 on 2007 Dodge Ram Truck