Troubleshooting AirLIft Wireless Controller with Fail Error Message
Question:
How can we fix it what does it mean Fail code airlift air ride
asked by: Shell
Expert Reply:
Sounds like you have an Air Lift compressor with a digital display.
The Air Lift Wireless AIR Compressor System # AL74000 will show an error whenever there is any type of issue with the system.
Generally this is an issue with the remote communicating with the system, a blockage, or a leak. I would inspect the compressor system and all of the air lines to make sure there are no issues. You can check for leaks using soap and water. If you find a leak disconnect the hose and make sure the tubing is cut as square as possible. If you find a block you'll likely need to replace that piece of tubing.
If you don't find anything wrong with the system try to join the controller with the manifold again:
Set the manifold into join mode.
• Ground the join wire in the electrical harness.
• Locate the YELLOW join wire with heat shrink on the end in the harness.
• Remove the yellow wire from the cap leaving the cap atached to the
harness.
• Attach the exposed terminal to a good frame ground.
Cycle power to the manifold.
• Manifold will boot in join mode and will click the exhaust solenoid 5 times fast,
then 1 per second.
• The manifold will stay in join mode for 30 seconds allowing time to set the
controller into join mode.
Set the controller into join mode.
• Press UP and DN buttons together to enter Settings Mode.
• Press the M1 button when the display flashes “JOIn”.
• Use the up and down buttons to select which manifold to join with.
• JOIn r = Join with the manifold controlling the rear axle springs.
• JOIn F = Join with the manifold controlling the front axle springs.
• Press the M1 button to join the controller to the selected manifold.
• The display will show DONE when the joining process is complete.
• The M2 button will exit back to the settings mode.
• Press M2 button again to exit out of Settings Mode.
• Disconnect yellow wire from ground.
• Reinsert the yellow wire terminal into the molded cap
Product Page this Question was Asked From
Air Lift WirelessAIR Compressor System for Air Helper Springs - Remote - Bluetooth
- Air Suspension Compressor Kit
- Wireless Control
- Dual Path
- Digital Display
- 100 psi
- Air Lift
more information >
Featured Help Information
Instructions
Continue Researching
- Q&A: Torque Spec for Tightening Trailer Brake Assemblies to Trailer Spindle
- Q&A: Troubleshooting FAIL Message On Controller for Air Lift WirelessAIR Compressor System
- Q&A: The Remote Says Fail, Is There A Reset On The Air Lift WirelessAIR Compressor System
- Q&A: When Should Trailer Wheel Bearings be Replaced
- Q&A: Trailer Wheel Seems Stiff, Not as Easy to Turn After Repacking Bearings with Grease
- Shop: Dexter Nev-R-Adjust Electric Trailer Brakes - 10" - Left/Right Hand Assemblies - 3.5K
- Video: Dexter Nev-R-Adjust Electric Trailer Brake Kit Installation
- Article: Trailer Wiring Diagrams
- Search Results: 25580
- Shop: Suspension Enhancement
- Video: etrailer Electric Trailer Brake Kit Installation
- Shop: etrailer Electric Trailer Brakes - Self-Adjusting - 12" - Left/Right Hand - 5.2K to 7K
- Q&A: Replacement Drum Brake Actuator for a 1995 4 Winns Model 3916 Trailer
- Article: Most Popular Wheel Bearings
- Search Results: trailer brakes
- Shop: Trailer Wiring
- Shop: etrailer Electric Trailer Brakes - Self-Adjusting - 10" - Left/Right Hand Assemblies - 3.5K
- Q&A: How to Measure to Determine the Size Trailer Brakes Needed For Hydraulic Drum Replacement
- Shop: Trailer Hitch
- Article: Trailer Tire Sizing
- Search Results: 10~36
- Video: K-Source Snap & Zap Custom Towing Mirrors Installation - 2023 Ford F-150
- Shop: Brake Controller
- Shop: etrailer Electric Trailer Brakes - 12" - Left/Right Hand Assemblies - 5,200 lbs to 7,000 lbs
- Article: Parts Needed to Add Electric Drum Brakes to a Trailer
- Search Results: trailer brake controller
- Shop: Gooseneck Hitch
- Shop: etrailer Electric Trailer Brakes - 10" - Left/Right Hand Assemblies - 3,500 lbs
- Search Results: brake controller
- Shop: Towing Mirrors