How Tight Should Shackle Straps and Bolts Be Tightened On Trailer
Question:
I have replaced the shackle straps on my double axle trailer, should the middle bolt that attaches the equalizer to the frame be loose enough so that the equalizer can float between the two leaf springs? Also how tight should the shackle bolts be?
asked by: Bob S
Expert Reply:
There is no specific torque rating for shackle bolts. Basically for the middle bolt there should be enough free play in the shackles to allow them to move.
Tightening the shackle bolts too much will squeeze the shackle straps against the leaf springs and the whole suspension system will bind and cause problems. The best thing to do when tightening down shackle bolts is to use lock nuts and tighten them until they are snug and then backed off 1/4 turn. Lock nuts should be used because they resist loosening with vibration or torque.
I have attached a helpful article that explains trailer suspension you can check out. I have also attached a video about replacing shackle bolts you can take a look at.
Product Page this Question was Asked From
Dexter Heavy-Duty Suspension Kit for Tandem-Axle Trailers - 1-3/4" Wide Double-Eye Springs
- Trailer Leaf Spring Suspension
- Suspension Kits
- Boat Trailer
- Camper
- Car Hauler
- Snowmobile Trailer
- Utility Trailer
- Double Eye Springs
- Tandem Axle
- Dexter
more information >
Featured Help Information
Miscellaneous Media
Continue Researching
- Q&A: Recommended U-Bolts And Plate For A 1-1/2" Wide Square Axle
- Q&A: How Tight Should Shackle Bolts Be Tightened On Trailer
- Shop: Suspension Kit for Tandem-Axle Trailers - 1-3/4" Wide Double Eye Springs - 2-1/4" Links
- Shop: Nylon Bushing - 9/16" Inner Diameter, 11/16" Outer Diameter - 1-3/4" Long
- Shop: Replacement Shackle Strap - 2-5/8" Long
- Shop: Brake Controller
- Article: Double-Eye Trailer Suspension System Review
- Shop: MORryde Suspension Upgrade Kit for Tandem Axle Trailers - 3-1/8" Long Shackle Straps
- Shop: 4-Leaf Double-Eye Spring for 3,500-lb Trailer Axles - 27" Long
- Shop: Shackle Bolt with Locknut for Double-Eye Springs - 3" Long
- Shop: Shackle Strap - 3-1/8" Long
- Article: How to Tell the Weight Rating of a Trailer Axle
- Shop: Trailer Wiring
- Article: How to Accurately Measure Trailer Leaf Springs
- Search Results: 1 7/8 socket
- Shop: Suspension Enhancement
- Search Results: f22zr
- Q&A: Can 26 Inch 3,500 lb Leaf Springs be Replaced With 4,000 lb Leaf Springs
- Shop: RV Jack Pads
- Article: Trailer Wiring Diagrams
- Search Results: leaf spring hanger
- Search Results: leaf spring hangers
- Search Results: leaf spring shackles
- Shop: Trailer Hitch
- Search Results: leaf spring hanger kit
- Search Results: grease seal 10~19
- Article: Towing a Trailer? Let's Talk About Brake Controllers
- Q&A: What is Difference Between Trailer Bearings L44649 vs L44643
- Video: etrailer Trailer Brakes - Electric Drum Brakes - AKEBRK-35-SA Review
- Video: Review of etrailer Trailer Hubs and Drums - Hub with Integrated Drum - AKHD-545-35-EZ-K
on Trailer Leaf Spring Suspension
