Replacing 6-Way Square Connector on Jayco Trailer and Using Adapter # 30104

Question

Question:

This is concerning a 95 jayco jay series camper. I noticed that the adapter plug going to the trailer was damaged on the 6 square side. So I purchased part #30104 from etrailer. Then noticed that the 6 square plug on the trailer had one of the poles broken off in it and could not remove it. My question is will part #37995 work on the part I ordered if I splice into the wires on the trailer and install it.

asked by: Jason

0

Expert Reply:

The Jayco 6-Way square connector is unique to those trailers and # 37995 wouldn't be a good fit for adapter # 30104. But, it you were to order # 37995 any way you could use it by replacing the 6-Way end on # 30104 with the vehicle side 6-Way that comes with # 37995.

expert reply by: Michael H

0

Answer 1

We do have 6-Pole Square Trailer Wiring Connector Kit (Car and Trailer Ends) #37995 that you can use for your Arctic Fox camper. This is both the male and female ends. But the wires on them are 18 gauge. You could replace the ground and power wires…

view full answer...

Answer 2

Replacing the wiring harness on your 1976 Jayco Eagle pop up trailer should be fairly easy. If your trailer is set up with brake/turn signals, and tail lights only then I would remove the factory square 6-way wiring connector and replace it with a…

view full answer...

Answer 3

Jayco is the only manufacturer that uses that type of 6-Way connector. We do not have a replacement that is going to work. Since yours is broken this is the perfect time to install a 7-Way connector on the trailer so you do not have to mess with…

view full answer...

Answer 4

There is no adapter available that will go from a 7-Way vehicle side connector to a 6-Way square Jayco connector. You will need to make one using the follow parts: 7-Way trailer connector #H20042 6-Pole Square Trailer Wiring Connector Kit, #37995…

view full answer...

Answer 5

Actually, using the #37220BL tank holder which is purposely designed to hold two 20lb tanks on the trailer tongue would likely be a better option. The Rhino Rack #RRRGBH4 is designed to mount to a roof rack mounted platform, and does include…

view full answer...

Answer 6

In order to determine the torque rating for the lug nuts on your trailer you will need to know check out the chart I attached that shows all of the torque specs for all the trailer lugs available based on stud size, wheel material and wheel size.

view full answer...

Answer 7

A 4-Way trailer connector has the basic lighting functions only; running lights, left turn signal and brake lights, right turn signal and brake lights, and ground. A 7-Way has these functions and a 12 volt circuit, a circuit for electric trailer…

view full answer...

Answer 8

The difference between the Class II and Class III hitches has to do with their Gross Trailer Weight (GTW), their Tongue Weight (TW), and their Hitch Receiver Size. Class II trailer hitch receivers have a 1-1/4 inch receiver and can be rated up to…

view full answer...

Answer 9

Even though I cannot comment specifically on the grease you used because I am not familiar with it, I can tell you the best grease for trailer bearings is a a grease with a rating of GC-LB, which just means it is made to withstand very high…

view full answer...

Answer 10

A BT8 spindle would have a diameter of .99 of an inch where the bearings would both install and would have a diameter of 1.24 where the great seal would ride. That would require a hub part #AKIHUB-440-2-1K for an idler hub. A BTR spindle would have…

view full answer...

Answer 11

Hey Jeremy, Typically with boat trailers the manufacturer will install hydraulic surge brakes because you don't have to worry about the water damaging wires like you would with electric brakes. That being said, if you use a heat shrink butt…

view full answer...

Answer 12

The difference between an load range C and load range D tire in the same size is the capacity and psi rating. The two tires will still have the same dimensions and fit on the same wheel. The D rated tire has a higher capacity. For a ST175/80D13 like…

view full answer...

Replacing 6-Way Square Connector on Jayco Trailer and Using Adapter # 30104

Products Referenced in This Question

Continue Researching