Will TruRyde Self Adjusting Brakes Replace Kelsey Hayes 602027 & 602028 Electric Brakes?

Question

Question:

Will your TRU36FR brake assemblies replace Kelyse Heyes RH 602027 and LH 602028 baking plates? The Kelsey Hayes backing plates have 7/16 mounting bolts on 2 3/4 centers. Thanks

asked by: Franklin K

0

Expert Reply:

Yes, the Self-Adjusting TruRyde Electric Trailer Brake Kit # TRU36FR will fit as a replacement for your Kelsey Hayes 602027 and 602028. I recommend getting the Mounting Hardware # BRKH10B as the original hardware often times becomes damaged during removal due to corrosion.

Be sure to inspect your Drums # AKHD-545-35-EZ-K to determine if they will also need to be need replaced.

expert reply by: Bud M

0

Answer 1

The correct replacement braking assemblies for the Kelsey Hayes 602027 and 602028 is the Electric Trailer Brake Kit part #AKEBRK-35. These will be direct bolt-on replacement. I would add the Mounting Hardware for 10" Brake Assemblies part…

view full answer...

Answer 2

In order to determine the torque rating for the lug nuts on your trailer you will need to know check out the chart I attached that shows all of the torque specs for all the trailer lugs available based on stud size, wheel material and wheel size.

view full answer...

Answer 3

The difference between the Class II and Class III hitches has to do with their Gross Trailer Weight (GTW), their Tongue Weight (TW), and their Hitch Receiver Size. Class II trailer hitch receivers have a 1-1/4 inch receiver and can be rated up to…

view full answer...

Answer 4

To determine the size of the brake assemblies you need you have to measure the depth and width of the hub drum on the axle like what you see in the picture I attached. The most common size is 2-1/4 inch wide like the #T4071600-500 that you…

view full answer...

Answer 5

To find the load capacity for your axle you should look on the trailer VIN plate or sticker that lists the VIN number. The weight rating of the axle should be listed on that same plate or sticker. Also, the axle could have a tag or plate on it that…

view full answer...

Answer 6

The difference between an load range C and load range D tire in the same size is the capacity and psi rating. The two tires will still have the same dimensions and fit on the same wheel. The D rated tire has a higher capacity. For a ST175/80D13 like…

view full answer...

Answer 7

To determine the size of the hub assembly you need to purchase you have to determine which bearings are in the old assembly. If the old assembly has L44649 inner bearings, you would use the hub you chose #8-258-5UC1. If the inner bearings are marked…

view full answer...

Answer 8

A 4-Way trailer connector has the basic lighting functions only; running lights, left turn signal and brake lights, right turn signal and brake lights, and ground. A 7-Way has these functions and a 12 volt circuit, a circuit for electric trailer…

view full answer...

Answer 9

For a single axle trailer, you want the shackle strap to be able to move so that you have the spring deflection needed for your suspension. Angled like the photo or even almost vertical is fine you just don't want the shackle strap to bind and…

view full answer...

Answer 10

Even though I cannot comment specifically on the grease you used because I am not familiar with it, I can tell you the best grease for trailer bearings is a a grease with a rating of GC-LB, which just means it is made to withstand very high…

view full answer...

Answer 11

I did some checking and the hub/drum we offer that will work for you is the part #8-430-5UC3. This uses the same bearings as the 8-415 and will be an exact fit aside from the fact this is a non-ABS setup and the 8-415 came in an ABS setup and non-ABS…

view full answer...

Answer 12

The spring hanger placement is going to be determined by your axle spacing. For example, if your axles are spaced 33 inches apart, as shown in the attached diagram, a 7K axle slipper spring, like #e74SR, requires a distance of 28-1/2 inches between…

view full answer...

Will TruRyde Self Adjusting Brakes Replace Kelsey Hayes 602027 & 602028 Electric Brakes?

Products Referenced in This Question

Product Page this Question was Asked From

Continue Researching