Is There Similar Product To Timbren Axless-Less Suspension Compatible With A Triple Axle Setup
Question:
Hi Kevin, thanks for coming back to me. My idea is to build a 8000lb caravan using tyre-axle instead of twin. The reason is that each axle is then lower rated and therefore has a softer ride and the caravan is much more stable on the road and much less likely to snake. An independent suspension is much nicer to the chassis and allows a much softer ride. If Timbren does not allow to use their suspension as tri-axle setup, is there a similar suspension out please? with kindest regards
asked by: Uwe
Expert Reply:
Axles are there to support the weight of the trailer so increasing the number of axles would not result in a softer ride quality like you're thinking. The suspension, whether it's leaf springs or Timbrens, would be the determining factor in ride quality. There isn't a similar product out there to match Timbren's axle-less suspension that could be used in a triple axle setup.
A Timbren Axle-less suspension like # ASR2KHDS03 would be a great option if you were going off-road since leaf springs typically can't handle the bouncing from a rough terrain and could potentially crack, snap, or flatten out. This is why SuperSprings International and Timbren made bumpstocks for leaf spring suspensions to help cushion and support the loads on a trailer. Leaf spring suspensions along with suspension enhancements tend to be quite a bit cheaper than the a Timbren axle-less suspension as well.
Triple axle trailers can still experience sway depending on how you load the trailer. Too much or too little tongue weight can vastly change how the trailer tracks behind the tow vehicle. Independent suspension could actually cause more stress to the frame of the trailer since it's directly mounted to it and puts more pressure on the chassis that a typical axle/leaf spring setup. If you read the fine print for one of these systems they tell you install supports between the frame beams where these are installed to prevent them from potentially bending the frame.
If you don't plan on taking the trailer off-road over rough terrain then I recommend using an axle and leaf spring suspension and picking up some suspension enhancement like the # TSS-106-40 (fitment depends on the axle capacity and leaf spring orientation) to help soften the ride quality.
Products Referenced in This Question
SumoSprings Trailer Helper Springs w/ Line Relocation Bracket - Single Axle - 3K to 5K - Underslung
- Trailer Leaf Spring Suspension
- Leaf Spring Enhancement System
- Boat Trailer
- Camper
- Car Hauler
- Snowmobile Trailer
- Utility Trailer
- Jounce Springs
- 3000 lbs
- 4000 lbs
- 5000 lbs
- Single Axle
- SuperSprings Intl
more information >
Product Page this Question was Asked From
Timbren Axle-Less Trailer Suspension - Heavy Duty - Long Spindle w/ 4" Lift - 4 Bolt - 2K
- Trailer Axles
- Rubber Spring Suspension
- Easy Lube Spindles
- No Hubs
- 2000 lbs
- Spindles Only
- Universal Fit
- Lift - 4 Inch
- Timbren
more information >
Featured Help Information
Instructions
Continue Researching
- Video: SuperSprings SumoSprings Trailer Helper Springs Review
- Shop: Timbren Silent Ride Suspension for Tandem Axle Trailers w/ 3" Round Axles - 14,000 lbs
- Shop: SumoSprings Trailer Helper Springs w/ Line Relocation Bracket - Single Axle - 3K to 5K - Underslung
- Q&A: Can Timbren Axle-Less Trailer Suspension Kits Be Used On Triple-Axle Trailers
- Q&A: Dimensions of the Timbren Heavy-Duty Axle-Less Trailer Suspension # ASR2KHDS03
- Q&A: What is the Widest Tire That Will Fit the Timbren Heavy-Duty Axle-Less Trailer Suspension
- Shop: Westlake ST235/75R15 Radial Off-Road Trailer Tire - Load Range D
- Shop: Easy Grease Trailer Hub and Drum Assembly for 3.5K Axles - 10" - 5 on 4-1/2 - Pre-Greased
- Shop: Timbren Axle-Less Trailer Suspension - Heavy Duty - Long Spindle w/ 4" Lift - 4 Bolt - 2K
- Shop: Suspension Enhancement
- Article: Trailer Tire Sizing
- Search Results: leaf spring
- Q&A: Lug Nut Torque Chart for Trailer Wheels
- Shop: MORryde Suspension Upgrade Kit for Tandem Axle Trailers - 2-1/4" Long Shackle Straps
- Search Results: equalizer
- Article: How to Measure the Bolt Pattern of a Trailer Wheel
- Shop: SumoSprings Trailer Helper Springs w/ Line Relocation Bracket - Single Axle - 5K to 8K - Overslung
- Shop: Trailer Hitch
- Article: Trailer Wiring Diagrams
- Shop: Trailer Wiring
- Search Results: lug nuts
- Search Results: lug nut
- Shop: Gooseneck Hitch
- Article: Most Popular Wheel Bearings
- Shop: Fifth Wheel Hitch
- Search Results: fender
- Video: Dexter Trailer Springs Over-Under Conversion Kit Installation K71-384-00
- Article: 7 Common Questions Everyone Has About Trailer Tires
- Video: Timbren Axle-Less Trailer Suspension System Installation
- Search Results: sumosprings