Air Force One Supplemental Braking System Actuates Vehicle Brakes When Not Attached to RV
Question:
Why would this happen ? The car was not being towed . Car dealer says there is nothing wrong with the vehicle it must be the airforce one system. Where do I go with this issue. Afraid to drive my explorer now for fear this will happen again.
asked by: Nancy E
Expert Reply:
I spoke with my contact at SMI, the manufacturer of the Air Force One braking system. He had a few possibilities that he recommended you have checked.
Where the cable that joins the actuator cylinder on the brake pedal, make sure that there's about 1/4 to 1/2 an inch of slack in the cable. Also, if the vehicle has adjustable pedals, make sure that the pedals are move as close to the seat as they'll go when the tension on the cable is set. This procedure is outlined in Step 7 of the installation instructions, on page 14.
Also, check the break away pin at the front of the vehicle. If the pin isn't pushed in all the way, it would cause the brakes to actuate.
Product Page this Question was Asked From
Demco Air Force One Flat Tow Brake System for RVs w/ Air Brakes - Proportional
- Tow Bar Braking Systems
- Brake Systems
- Proportional System
- One Time Set-Up
- Fixed System
- Power Assist Brake Compatible
- Air Brakes
- Demco
more information >
Featured Help Information
Instructions
Continue Researching
- Shop: Vehicle Tow Bar Brake System
- Shop: Demco Air Force One Flat Tow Brake System for RVs w/ Air Brakes - Proportional
- Shop: Vehicle Tow Bar Wiring
- Shop: Roadmaster Stop Light Switch Kit
- Video: Roadmaster Stop Light Switch Kit Review RM-751200
- Q&A: Can the SMI Air Force One Braking System be Installed if Vehicle Has Adjustable Pedals
- Q&A: Does the Reed Switch Eliminate the Brake Light Switch on an SMI Braking System
- Q&A: Monitor Light In Motorhome and Vehicle Brake Lights On With SMI Air Force One
- Q&A: Does LED Indicator Light of SMI Air Force One Light Up When Vehicle isn't Connected
- Shop: Adapter 7-Pole to 6-Pole Universal with LED Tester
- Shop: Roadmaster Universal Braking Monitor for Flat Tow Brake Systems
- Shop: Replacement Braking Indicator Light for Roadmaster BrakeMaster Systems
- Shop: Roadmaster 4-Diode Universal Wiring Kit for Towed Vehicles - 7-Wire to 6-Wire Straight Cord
- Video: Hopkins Wiring - Wiring Adapters - 47525 Review
- Video: Roadmaster 4-Diode Universal Wiring Kit Installation - 2013 Ram 1500
- Video: Review of Roadmaster Tow Bar Braking System Parts - Replacement Monitor Light - RM-300065-00
- Video: Roadmaster Universal Brake Monitor Review
- Search Results: air force one
- Shop: Towed Vehicle Battery Charge Line Kit for Demco Air Force One and Stay-IN-Play Duo Braking Systems
- Search Results: tow bar braking systems
- Video: SMI Air Force One Braking System Installation - 2019 Ram 1500
- Q&A: Is a Third Check Valve Needed for the SMI Air Force One on a 2018 Ford Edge
- Q&A: Installing SMI Air Force One Supplemental Braking System on 40 Foot Dutchcraft on Spartan Chassis
- Q&A: How to Make Vaccuum Line Connection for SMI Air Force One on 2018 Jeep Wrangler JL
- Video: Demco SBS Air Force One Coach Air Kit Installation - 2018 Tiffin Allegro Red Mot
- Search Results: air force one brake system
- Article: Trailer Wiring Diagrams
- Search Results: base plates
- Shop: Trailer Hitch
- Article: Brake Controller 7- and 4-Way Installation Kit (ETBC7)