Converting Military Trailer W/ Air Assist Hydraulic Drum Brakes to an Electric Over Hydraulic System
Question:
I have a 5 ton military trailer with air assit hydraulic drum brakes single axle converted to a log carrier. I have a 2000 Dodge 2500 4 wheel diesel with factory 7 way trailer plug. I am looking for best option for possible elect over hydraulic control of the drum brakes.
asked by: Mike
Helpful Expert Reply:
From a price, performance and reliability standpoint, I would recommend the Carlisle HydraStar Electric Over Hydraulic Actuator for drum brakes, part # HBA-10. You would also need a breakaway kit like the # 50-85-313 offered by Tekonsha as well as an in-cab brake controller that is electric over hydraulic compatible, like the Tekonsha Prodigy P2, part # 90885 or the P3, part # 90195. Both controllers are electric over hydraulic compatible, but the P3 is a bit more user-friendly for those who are not familiar with brake controllers. To install the controller, you would need the brake control wiring adapter, part # 3020-P. The controller would install as outlined in the install video I have linked you to.
The HBA-10 is compatible with typical 3/16 inch brake lines.
Products Referenced in This Question
Tekonsha Plug-In Wiring Adapter for Electric Brake Controllers - Dodge
- Accessories and Parts
- Trailer Brake Controller
- Wiring Adapter
- Plugs into Brake Controller
- Vehicle Specific
- Tekonsha
more information >
Tekonsha Push-To-Test Trailer Breakaway Kit with Built-In Battery Charger - Top Load
- Trailer Breakaway Kit
- Kit with Charger
- Top Load
- Single-axle
- Tandem-axle
- Triple-axle
- LED Tester
- Tekonsha
more information >
Tekonsha Prodigy P3 Trailer Brake Controller - 1 to 4 Axles - Proportional
- Trailer Brake Controller
- Proportional Controller
- Electric
- Electric over Hydraulic
- Automatic Leveling
- Under-Dash Box
- Dash Mount
- Up to 4 Axles
- LCD Display
- Up to 360 Degrees
- Tekonsha
more information >
Tekonsha Prodigy P2 Trailer Brake Controller - 1 to 4 Axles - Proportional
- Trailer Brake Controller
- Proportional Controller
- Electric
- Electric over Hydraulic
- Automatic Leveling
- Under-Dash Box
- Dash Mount
- Up to 4 Axles
- LED Display
- Up to 360 Degrees
- Tekonsha
more information >
Hydrastar Electric Over Hydraulic Actuator for Drum Brakes - 1,000 psi
- Brake Actuator
- Electric-Hydraulic Brake Actuator
- 1000 psi
- Drum Brakes
- Hydrastar
more information >
Product Page this Question was Asked From
Dexter BrakeRite II Electric Over Hydraulic Actuator Kit - Vented - 1,500 psi
- Brake Actuator
- Electric-Hydraulic Brake Actuator
- Disc Brakes
- Dexter
more information >
Featured Help Information
Instructions
Miscellaneous Media
Continue Researching
- Q&A: How Do I Measure the Drop Distance on a Trailer Drop Axle?
- Article: How to Replace or Install an RV Roof Vent
- Q&A: Replacement Disc Brake Caliper for a Tie Down Engineering 46304 Caliper
- Q&A: Replacement For Dexter DX12.5 Brake Actuator on Boat Trailer
- Q&A: Replacement RV ladder for 2007 Monaco Diplomat
- Article: Adding Electric Over Hydraulic Disc Brakes
- Q&A: Replacement Hub Needed for Lippert 122093 Hub on 5,200 lbs Axle
- Q&A: Will the Draw-Tite Trailer Hitch Fit a 2022 Volvo XC90 Recharge
- Article: How to Charge a Trailer Battery While Driving: 3 Common Problems (And How to Fix Them)
- Q&A: Comparison between Kuat Transfer and Swagman Chinook Bike Racks
- Article: Trailer Wiring Diagrams
- Article: Parts Needed to Add Hydraulic Disc Brakes to a Trailer
- Article: Brake Controller 7- and 4-Way Installation Kit (ETBC7)
- Article: 2023 Best Gifts for Outdoor Enthusiasts