Troubleshooting Barker VIP 3500 Electric A-Frame Trailer Tongue Jack
Question:
The electric jack will not work. When I remove the drive gear I can manually raise and lower the jack. When the drive gear is removed the motor seems to work fine. When the drive gear is in place and I try to manually crank it I get a loud click from the gear box in both directions. Any ideas?
asked by: Les H
Expert Reply:
When an electric trailer tongue jack like the Barker VIP 3500 will not operate with electric power the two most common causes are a weak ground connection or a battery with an insufficient charge.
I checked the online installation/operation instructions for this item. These note that since the jack grounds through its round mounting plate a toothed washer should be used on the mounting bolts to bite into the metal at the trailer mount to make a good ground. It is usually best to first sand off that mounting point on the trailer and also the bottom side of the jack's round mounting plate. This lets you have the good metal-on-metal contact needed for a good ground.
What can happen is that over time water and dirt will work their way into the gap between the jack plate and the frame. Eventually this can disrupt the ground and prevent full current from the battery from reaching the jack motor. The instructions further note to use 12-gauge wire for the battery + connection, which is made through a 30-amp fuse.
Note that just because the lights built into the jack function well this does not mean the battery has enough current for the motor. Lights on a jack are usually quite small and demand little power, especially if they are efficient LED lights. Your battery may be able to light up the jack no problem but still not have the charge needed to operate the motor.
Now as to the matter of the clicking noise you hear when you manually crank the jack this is typically related to the gearbox. We do not carry the VIP brand of jacks or their replacement parts but their maker, H&H Engineering, can be reached in Michigan at (269) 965-2371. Your jack includes a torque limiter which could be what is making the noise.
A superior-quality jack you might consider if you plan to replace yours is the Stromberg Carlson Electric Trailer Jack - Drop Leg - A-Frame - 23" Lift - 5,000 lbs - Black, Item # JET-5000.
Product Page this Question was Asked From
Stromberg Carlson Electric Trailer Jack - Drop Leg - A-Frame - 23" Lift - 5,000 lbs - Black
- Camper Jacks
- Pop Up Camper
- Teardrop Camper
- Travel Trailer
- Leveling Jacks
- Tongue Jack
- Steel
- 4001 - 5000 lbs
- Electric Jack
- 23 Inch Lift
- Bolt-On
- 1 Jack
- Stromberg Carlson
more information >
Continue Researching
- Shop: Kenda Karrier S-Trail ST145/R12 Radial Trailer Tire - Load Range E
- Shop: Kenda Karrier ST145/R12 Radial Trailer Tire with 12" Black Mod Wheel - 5 on 4-1/2 - LR D
- Shop: Stromberg Carlson Electric Trailer Jack - Drop Leg - A-Frame - 23" Lift - 5,000 lbs - Black
- Shop: RV Exterior Lighting
- Search Results: porch
- Shop: LED Porch Light for RVs - Weatherproof - 190 Lumens - Clear Lens
- Shop: LED Trailer Clearance or Side Marker Light w/ Reflex Reflector - Submersible - 3 Diodes - Amber Lens
- Shop: Gustafson 12V RV Porch Light - 12" Long x 5" Wide - Black
- Shop: Bulldog Powered Drive Trailer Jack - Drop Leg - A-Frame - 22" Lift - 4,000 lbs - Black
- Search Results: barker jack
- Q&A: Will Bulldog Powered Drive Trailer Jack BD500199 Replace Manual Jack w/Triangle Mounting Bracket
- Shop: Brake Controller
- Search Results: husky hb4500
- Q&A: Trailer Jacks Manufactured in the USA
- Q&A: Troubleshooting Electric Trailer Jack Not Working With Fully Charged Battery
- Shop: Suspension Enhancement
- Q&A: Troubleshooting Huskey Brute Electric Trailer Jack That Retracts But Doesnt Extend
- Search Results: tongue jack
- Q&A: Is There a Power A-Frame Jack That Can Rotate 90 Degrees
- Q&A: Can The Bulldog Powered-Drive Trailer Jack # BD500199 be Installed in a 90 Degree Orientation
- Q&A: What is Included With the Bulldog BD500199
- Video: Bulldog Powered Drive Trailer Jack Review
- Search Results: electric leveling jacks
- Shop: Truck Bed Mat
- Shop: Towing Mirrors
- Shop: Truck Bed Tailgate Assist
- Shop: Tire Chains
- Video: Stromberg Carlson Electric Trailer Jack Review JET-5000
- Search Results: 3500 lb tongue jack
- Search Results: husky trailer jack