Troubleshooting No Power to Brakes Using Tekonsha Voyager on International Truck
Question:
I have a international truck with air brakes, brake controller has power coming in on black wire, ground has been checked ,and if i put test light to blue wire the light on controller lights up and can get light to change color when i apply controller manually but no power going to pigtail on truck
asked by: Dave
Expert Reply:
Since your brake controller has power and you checked the ground already we can rule that out. I'm also assuming your truck is wired for a brake controller like your Tekonsha Voyager # 39510 and you don't need an air-activated controller like the # HA100400C.
Assuming that is accurate, if I understand correctly you're testing for power on the blue wire and it checks out, but when you test at your 7-way connection you don't get anything. Based on this information I would say you have a short in the blue wire or you need to check and clean your 7-way socket on the vehicle.
Make sure your 7-way is free from any corrosion or debris, and doesn't have any damage. If that checks out, then I would use the circuit tester and work my way along the blue wire while checking for a short. You may also need to run a new wire with the # 10-1-1.
I have attached a helpful article on troubleshooting brake controllers for your reference.
Products Referenced in This Question
Hayes Air Actuated Trailer Brake Controller - 1 to 4 Axles - Proportional
- Trailer Brake Controller
- Proportional Controller
- Air to Electric
- Electric over Hydraulic
- Manual Leveling
- Under-Dash Box
- Dash Mount
- Up to 4 Axles
- Indicator Lights
- Up to 360 Degrees
- Hayes
more information >
Product Page this Question was Asked From
Tekonsha Voyager Trailer Brake Controller - 1 to 4 Axles - Proportional
- Trailer Brake Controller
- Proportional Controller
- Electric
- Manual Leveling
- Under-Dash Box
- Dash Mount
- Up to 4 Axles
- Indicator Lights
- Up to 90 Degrees
- Tekonsha
more information >
Featured Help Information
Instructions
Miscellaneous Media
Continue Researching
- Article: Brake Controller 7- and 4-Way Installation Kit (ETBC7)
- Article: Brake Controller Installation: Starting from Scratch
- Article: Trailer Wiring Diagrams
- Article: Towing a Trailer? Let's Talk About Brake Controllers
- Article: Installing an Electric Brake Controller on 2007-2013 GM Full-Size Truck or 2007-Present GM SUV
- Q&A: Replacement Hub for Hammer Blow Hub Part HB732 on Old Trailer
- Q&A: Recommended Replacement for Atwood OD5001CW Direct Water Heater
- Article: Wiring Trailer Lights with a 7-Way Plug (It's Easier Than You Think)
- Article: 5 Things to Know About Weight Distribution Hitches
- Q&A: Most Concealed Hitch for a 2023 Subaru Ascent
- Q&A: How Do I Add a 7-Way Connector to a 2023 Subaru Ascent?
- Q&A: Replacement Motor For Power Gear Part 1510000006 On 2006 Fleetwood Fista
- Q&A: Replacement Water Heater for Atwood GC10A-3E
- Q&A: Replacement Thermostat for Dometic 3316410.012 Thermostat