How to Repair Jammed Fulton 1000 lb Capacity Trailer Jack
Question:
older 1000 lb fulton jack will not go up or down. the top cap looks to be welded? can it be rmove by grinding the weld and if yes can i be repaired without rewelding?
asked by: Roger H
Expert Reply:
If the jack is stuck in the fully extended or retracted position, it's likely that the jack has been over extended which jams the internal screw into the nut. When this occurs, the best bet would be to replace the jack.
The Fulton # FXP10 which offers a 1200 lb capacity and up to 12 inches of lift would be a fine replacement if the 12 inch lift is sufficient for your needs.
If your current jack is jammed in between full extension and retraction, it's possible that the bevel gears are damaged. If that's the case, we might have replacement gears.
If you could provide me with the part number of your jack, I can check on the availability of replacement parts, and determine how to replace the cap if possible.
Product Page this Question was Asked From
Fulton Bolt-Thru Swivel Marine Jack w/ Caster - Sidewind - 10" Lift - 1,200 lbs
- Trailer Jack
- Boat Trailer
- Leveling Jacks
- Tongue Jacks
- Steel
- 1001 - 2000 lbs
- Sidewind Jack
- Swivel Jack
- 10 Inch Lift
- Bolt-On
- With Wheel
- Fulton
more information >
Continue Researching
- Shop: Fulton Bolt-Thru Swivel Boat Trailer Jack w 2 Wheels - Bolt On - Sidewind - 12" Lift - 1.5K
- Shop: Fulton Round, Snap-Ring Swivel Marine Jack - Weld On - Sidewind - 10" Lift - 1,200 lbs
- Video: Rebuilding a Fulton Jack
- Q&A: Trailer Stuck to Truck and Jack Wont Crank
- Shop: Fulton Bolt-Thru Swivel Marine Jack - Weld On - Sidewind - 10" Lift - 1,500 lbs
- Shop: Piranha LED Trailer Clearance and Side Marker Light - 5 Diodes - Amber Lens
- Shop: Right Angle 2-Wire Pigtail for Optronics Trailer Lights - 2-Prong PL-10 Plug - 6" Lead
- Shop: LED Trailer Clearance and Side Marker Light w/ Flange - Submersible - 5 Diodes - Round - Amber Lens
- Shop: LED Clearance and Side Marker Trailer Light w/ Flange - Submersible - 7 Diodes - Round - Amber Lens
- Video: Ark Xtreme Off-Road Ratcheting Trailer Jack Review
- Video: Ark Extreme Off-Road Trailer Jack Review
- Search Results: fulton jack
- Search Results: trailer jack ram 2000
- Search Results: 10 ply 16" tires
- Q&A: Troubleshooting Electric Trailer Jack Not Working With Fully Charged Battery
- Q&A: Wiring Diagram/Colors for Installing Curt Venturer Brake Controller
- Q&A: How to Replace Interior Ram Jack Rod and Nut # TJD-12000-RODNUT on 12000 Series Jacks
- Article: Wiring Trailer Lights with a 7-Way Plug (It's Easier Than You Think)
- Article: Trailer Wiring Diagrams
- Article: Troubleshooting Brake Controller Installations
- Shop: Trailer Hitch
- Q&A: Dimensions of Dutton-Lainson Round Swivel Jack DL22335
- Q&A: Difference Between Dexter DX7.5L A-60 & A-60XL Disc Brake Actuator
- Q&A: Replacemnet Surge Brake Actuator For a Tie Down Engineering LP7000
- Article: Best Boat Trailer Jacks
- Article: How to Measure for Trailer Hitch Drop
- Article: Trailer Maintenance Schedule
- Article: How to Bleed Your Trailer Surge Brakes