Full Suspension Upgrade For Lippert 7000 lb Axle On 2014 Grand Design 369RL
Question:
I have a 2014 Grand Design with 7,000 lb Lippert tandem axles on it. Could you figure up what I need for springs, shocks and a disc brake kit for it? I already upgraded to the CRE 3000.
asked by: Dusty
Expert Reply:
It is good to hear that you are upgrading the suspension components that your 2014 Grand Design 369RL came with from the factory. Most of the time if not every time the stock components are very poor in quality resulting in giving a poor driving experience. For your leaf springs we have one that may work but you will need to make some measurements to make sure they will work with your MORrydem CRE3000 system. The 6-Leaf Double-Eye Spring # e64SR are for 7,000-lb Trailer Axles and are 24-7/8" Long from the center of spring eye to the other center of spring eye. Part # e64SR is one spring so you will need to purchase two.
As far as shocks go, I recommend getting the Roadmaster Comfort Ride Shock Absorbers # RM-2470. For your disc break conversion what we need to look at is the inner and outer bearing numbers. Most 7,000 lb trailer axles use outer bearing number 14125A and inner bearing number 25580. The HydraStar Disc Brake Kit # HSE7K-T1 uses the same inner and outer bearing numbers and will work with your 7,000 lb axle. The HydraStar kit is an 8 on 6-1/2 pattern so you can put these nicer wheels on to compliment your new break assembly. I think the Castle Rock ST235/80R16 Radial Tire w/ 16" Bobcat Aluminum Wheel # LHACKSO513B would looke great. These wheels are 8 on 6-1/2 and match the factory size that came with your 2014 Grand Design. They are the 16 inch wheels that you need and are load range E tires.
If you didn't already have the MORryde CRE3000 I would recommend getting the Roadmaster Comfort Ride Leaf Spring Suspension Kit w/ Shocks # RM-2470-2580. I like buying a full kit to take all the work out of it. Kitted components always are the easiest to install and are designed to work together the best. I would recommend getting this kit over buying everything.
I've included a bunch of videos for you to watch so be sure to check those out!
Products Referenced in This Question
6-Leaf Double-Eye Spring for 7,000-lb Trailer Axles - 24-7/8" Long
- Trailer Leaf Springs
- Double Eye Springs
- 7000 lbs
- 1-3/4 Inch Wide
- 6 Leaf
- 24-7/8 Inch Long
- Painted
- etrailer
more information >
Hydrastar Disc Brake Kit w/ Actuator for Tandem Axle Trailers - 13" Hub/Rotor - 8 on 6-1/2 - 7K
- Trailer Brakes
- Disc Brakes
- Marine Grade
- 8 on 6-1/2 Inch
- Hub and Rotor
- 1/2 Inch Studs
- 7000 lbs Axle
- Hydrastar
more information >
Roadmaster Comfort Ride Shock Absorbers for Tandem Axle Trailers - 8,000-lb Axle
- Trailer Suspension Parts
- Suspension Kits
- Boat Trailer
- Camper
- Car Hauler
- Snowmobile Trailer
- Utility Trailer
- Shocks
- 8000 lbs
- Tandem Axle
- Roadmaster
more information >
Roadmaster Comfort Ride Leaf Spring Suspension Kit w/ Shocks - Tandem 8K, 3-1/2" Axles
- Trailer Suspension Parts
- Equalizer Upgrade Kit
- Leaf Spring Replacement System
- Suspension Kits
- Boat Trailer
- Camper
- Car Hauler
- Snowmobile Trailer
- Utility Trailer
- 8000 lbs
- Round Axle - 3-1/2 Inch
- Tandem Axle
- Roadmaster
more information >
Product Page this Question was Asked From
Hydrastar Disc Brake Kit w/ Actuator for Tandem Axle Trailers - 13" Hub/Rotor - 8 on 6-1/2 - 7K
- Trailer Brakes
- Disc Brakes
- Marine Grade
- 8 on 6-1/2 Inch
- Hub and Rotor
- 1/2 Inch Studs
- 7000 lbs Axle
- Hydrastar
more information >
Featured Help Information
Instructions
Miscellaneous Media
Continue Researching
- Q&A: Wiring Diagram for Trailer Breakaway Kit
- Q&A: Breakaway Switch Diagram for Installation on a Dump Trailer with Trailer Mounted 12 volt Battery
- Q&A: How to Find Breakaway Battery on Fifth Wheel Camper
- Shop: Replacement Access Door for Furrion RV Tankless Water Heater - 18" x 18"
- Shop: Furrion RV Tankless Water Heater - Gas - Automatic Pilot - 60,000 BTU - 16" x 16" Door
- Shop: Fogatti RV Tankless Water Heater - Gas - Automatic Pilot - 41,800 Btu - Black
- Shop: Furrion RV Tankless Water Heater - Gas - Automatic Pilot - 60,000 BTU - 18" x 18" Door
- Search Results: tankless water heater
- Article: Converting Your RV Water Heater to Tankless
- Q&A: Recommended Replacement For An Atwood GC6AA-10E Water Heater
- Shop: Trailer Hitch
- Shop: Furrion RV Tankless Water Heater - Gas - Automatic Pilot - 60,000 BTU
- Video: Furrion RV Tankless Water Heater Installation - 2016 Forest River Wildwood X-Lite Travel Trailer
- Video: Furrion RV Tankless Water Heater Review
- Shop: Dometic RV Water Heater - Gas and Electric - Automatic Pilot - 120 Volt - 10,000 Btu - 6 Gal Tank
- Article: Trailer Wiring Diagrams
- Shop: Suspension Enhancement
- Q&A: Direct Replacement Water Heater for Atwood Model GC10A-4E
- Search Results: water heater
- Search Results: furrion
- Video: Review of Excel RV Water Heaters - Tankless Ventless Water Heater - EX93FR
- Shop: Fifth Wheel Hitch
- Video: Review of Dometic RV Water Heaters - Gas and Electric Water Heater - DMC74FR
- Search Results: rv water heaters
- Shop: Trailer Wiring
- Q&A: Recommended Replacement for Atwood GC10A-4E RV Water Heater
- Shop: Excel RV Tankless Water Heater - Gas - Electric Ignition - Vent Free - 38,000 Btu
- Q&A: Recommended Replacement For An Atwood G6A-8E RV Water Heater
- Video: Furrion RV Tankless Water Heater Installation - 2019 Grand Design Momentum 5W Toy Hauler
- Search Results: butyl tape