Recommended Double Eye Leaf Springs and Hanger Kit for 3,500 Pound Axle Trailer
Question:
I have a single axle 5 X 8 utility trailer with a 3,500, 2.25inch diameter axle. I need to relocate my axle forward a bit since I added some length and weight to the trailer front end. I need to replace my existing 1.75inch wide leaf springs but I can re-use my existing U-bolts, plates and nuts. I will however need new pair of leaf springs, hangers, end bolts, shackle straps, shackle bolts and lock nuts. Which leaf spring would your recommend? Can you work me up a material list and price for your spring recommendation and the new components listed above? Thank you.
asked by: Scott R
Expert Reply:
For double eye leaf springs, I recommend going with the 4-Leaf Double-Eye Spring # SP210275. This spring is 25-1/8 inches long x 1-3/4 inches wide and designed for 3,500 pound axles. These springs are a common length for 3,500 pound trailers. One spring is included with the part number, so you will want to order 2 of the same spring in order to replace both sides.
A suspension kit will provide you with new hangers, shackle bolts, shackle straps, and locknuts needed for your new leaf springs. I recommend using either the # APS4 or # APS2 suspension kit. The # APS2 includes 1-1/2 inch front hangers and 1-1/4 inch rear hangers. The # APS4 has 3-1/4 inch front hangers and 1-1/2 inch rear hanger, and this kit will likely allow your trailer to ride approximately 1-1/2 inches higher than the # APS2.
Prices for the leaf springs and suspension kits are listed on their product pages, and in the product information located below my answer.
Products Referenced in This Question
Single-Axle Trailer Hanger Kit for Double-Eye Springs - 1-1/2" Front, 1-1/4" Rear
- Trailer Leaf Spring Suspension
- Hangers
- Suspension Kits
- Boat Trailer
- Camper
- Car Hauler
- Snowmobile Trailer
- Utility Trailer
- Double Eye Springs
- Single Axle
- etrailer
more information >
Single-Axle Trailer Hanger Kit for Double-Eye Springs - 3-1/4" Front, 1-1/4" Rear
- Trailer Leaf Spring Suspension
- Hangers
- Suspension Kits
- Boat Trailer
- Camper
- Car Hauler
- Snowmobile Trailer
- Utility Trailer
- Double Eye Springs
- Single Axle
- etrailer
more information >
Continue Researching
- Shop: Single-Axle Trailer Hanger Kit for Double-Eye Springs - 3-1/4" Front, 1-1/4" Rear
- Q&A: Do the Shackle Straps Go Inside or Outside the Leaf Spring Hanger
- Article: Where to Position the Trailer Axle?
- Video: etrailer Trailer Suspension - Leaf Spring Suspension - APS4 Review
- Shop: Single-Axle Trailer Hanger Kit for Double-Eye Springs - 1-1/2" Front, 1-1/4" Rear
- Q&A: Comparing the Single-Axle Trailer Hanger Kits for Double-Eye Springs APS1, APS2, and APS3
- Q&A: Installing Leaf Springs on Single Axle Trailer
- Shop: Bronze Bushing - 9/16" Inner Diameter, 11/16" Outer Diameter - 1-3/4" Long - Qty 1
- Shop: Bronze Spring Eye Bushing, 3/4" x 1" x 2-1/2"
- Shop: Coupler Pin - 5/16" Diameter x 2-9/16" Long
- Search Results: leaf spring hanger
- Search Results: fender
- Search Results: trailer fender
- Search Results: hitch pin
- Search Results: spring bushing
- Search Results: coupler pin
- Q&A: Are Bushings for Trailer Suspension Spring Hangers Required
- Q&A: Can Heavier Rated Leaf Springs than Needed be Used on a Trailer
- Shop: U-Bolt Kit for Mounting 3,500-lb, Round Trailer Axles - 5-1/2" Long U-Bolts
- Q&A: How Far Apart Should Hangers be Mounted for 27 Inch Leaf Springs
- Shop: Two Piece Nylon Bushing - Qty 4
- Search Results: leaf spring bushings
- Q&A: Replacement Bronze Bushing for the Trailer Leaf Spring PR4
- Video: Dexter Bronze Bushings Installation - 2019 CrossRoads Redwood Fifth Wheel
- Video: Dexter Heavy Duty Suspension Upgrade Kit Review
- Shop: Brake Controller
- Video: Dexter Axle Trailer Suspension - Leaf Spring Suspension - K71-384-00 Review
- Video: Wheel Stud Installation on a Boat Trailer
- Video: etrailer Trailer Suspension - Leaf Spring Suspension - 93003-3X Review
- Video: Dexter Nev-R-Adjust Electric Brake Assembly Installation