Trailer Brake Controller Either Locks Up Trailer Brakes or Doesnt Brake Enough
Question:
We have a new 1.5 ton camper trailer with adjustable electri brake controller. We cant get the right setting. It either locks or pushes the car/ Prado. We cant be sure which one. Any ideas?
asked by: Lee
Expert Reply:
It is possible that the brake controller is mounted outside of the range specified in its manual and that could cause some unwanted behavior. If it is a time delay controller then you may need to adjust both the gain (power output) and the sync (how long it takes to ramp up to the preset gain level).
You can also check to make sure both the trailer side and vehicle side connectors are clean and free of corrosion both on the pins as well as inside where the wires attach.
I have included some links on testing and troubleshooting brake controllers as well.
Product Page this Question was Asked From
Dexter Electric Trailer Brake Assembly - 10" - Right Hand - 3,500 lbs
- Accessories and Parts
- Trailer Brakes
- Electric Drum Brakes
- RH
- 3500 lbs
- Brake Assembly
- Manual Adjust
- 10 x 2-1/4 Inch Drum
- Dexter
more information >
Continue Researching
- Q&A: Replacement Dexter Brake Assemblies for 36-19 Assemblies
- Article: Trailer Wiring Diagrams
- Q&A: Replacement Dexter Trailer Brake Kit To Replace Dexter 36-19 Brake Assemblies
- Q&A: Replacement Hub and Brake Assemblies that Fit Sure Trac 3,500 lb Axle
- Article: How to Adjust Your Trailer Brakes | The Ultimate Guide
- Article: Breakaway Kit Installation for Single and Dual Brake Axle Trailers
- Q&A: Recommended Wet Bolt For Center Hole Of The CRE 3000 Equalizer
- Q&A: Replacement Trailer Hub and Drum and Brakes for AL-KO 8490 Axle
- Q&A: Replacement Bolt and Nut for MORryde Wet Bolt Kit part # MR46ZR
- Q&A: How to Initially Adjust the Dexter Nev-R-Adjust Electric Trailer Brakes
- Article: Trailer Tire Sizing
- Article: Testing Trailer Brake Magnets for Proper Function
- Article: Parts Needed to Add Electric Drum Brakes to a Trailer
- Article: How to Choose the Right Trailer Hitch Class