Installing A SmartPlug RV Power Inlet On A 2020 Airstream Caravel 19CB Travel Trailer
Question:
SmartPlug RV and Marine Power Inlet and Connector - 30 Amp - Stainless Steel I have a 2020 Airstream Caravel 19cb and would like to change to this plug system. Will it fit?
asked by: Paul B
Expert Reply:
Hi Paul,
You can definitely swap out your current power inlet to the SmartPlug RV and Marine Power Inlet # SM67FR, but you might need to make some adjustments to the cutout hole. Most of the SmartPlug inlets I've installed have all been fairly close to fitting to where I may have only needed a file to help with centering the inlet in the circle cutout by filing little notches for the square corners of the new inlet. A lot of the time they just pop in though.
I've attached a video below where I had to make a cover plate because the previous inlet was much larger that the plate for the inlet. I just cut a rectangle out of a piece of plastic we had in the shop, rounded the edges to match the cover plate of the inlet, and then cut a large enough hole for the inlet housing to pass through. You'll want to pick up some butyl tape # AL28FJ and non-sag sealant # 344270341437-1 (white) or gray # AL33KV to create a waterproof seal.
I'll walk you through the installation process in the video attached below.
Products Referenced in This Question
LaSalle Bristol XTRM Universal Non-Sag Sealant for RVs - White - 10.1 oz - Qty 1
- RV Roof Repair
- Sealant
- 10.1 oz
- Non-Sag
- Self-Leveling
- White
- LaSalle Bristol
more information >
Alpha Systems Butyl Tape for RV Weatherproofing - 20' x 1" x 3/16"
- RV Roof Repair
- Tape
- Butyl Tape
- 20 Feet Long
- Colors May Vary
- Alpha Systems
more information >
Alpha Systems 1010 Non-Sag Sealant for RVs - Gray - 10.3 oz - Qty 1
- RV Roof Repair
- Sealant
- 10.3 oz
- Non-Sag
- Gray
- Alpha Systems
more information >
Product Page this Question was Asked From
SmartPlug RV and Marine Power Inlet and Connector - 30 Amp - Stainless Steel
- RV Power Inlets
- Power Inlets
- 30 Amp Male Plug
- Square
- Stainless Steel
- SmartPlug
more information >
Continue Researching
- Q&A: Stainless Steel TV/Internet Inlet For A 2020 Airstream Caravel 19CB Travel Trailer
- Q&A: White MaxxFan Roof Vent Recommendation with Powered Fan, Lift and Remote
- Article: 30-Amp and 50-Amp RV Service: What's the Difference?
- Article: Trailer Tire Sizing
- Q&A: What Are the Dimensions of the 30 Amp SmartPlug RV Power Inlet and Connector
- Q&A: Does The AC Distribution Panel Of The PD4135K Power Center Need To Be Ground To The RV Chassis
- Q&A: Rough-In Required For The Lippert Flow Max RV Toilet
- Q&A: Recommended Wire Gauge For 30 Amp SmartPlug Inlet And Connector
- Q&A: Is TST TPMS for RVs with 6 Flow Through Tire Sensors Compatible with All Rubber Valve Stems
- Article: 4 Steps to Choosing Your 5th Wheel Pin Box
- Article: Trailer Wiring Diagrams
- Article: How to Measure for Trailer Hitch Drop
- Article: RV Propane 101: How Does My RV's Propane System Work?
- Article: Replacing the Bearing, Races and Seals on a Trailer Hub