Raising Trailer Suspension To Clear Rear Leaf Spring From Hitting The Crossmember
Question:
I have a dual axle utility trailer. I put on brand new 3500 lb axles. The trailer is sitting too low and the crossmember is resting on the rear of my spring. The unloaded trailer is measuring 26 in eye to eye. If I go to to a 4,000 lb spring with shortening it to the 25 and a quarter eye to eye Will that help raise the frame higher.
asked by: Ross
Expert Reply:
It appears you may have installed shackle straps which are longer than what you may have had. It appears your straps are either 3-1/8" # TRSL313 or 3-1/2" # TRSL350 and you likely only need a 2-1/4" # TRSL225. This would move the mounting point closer to the axle and raise the trailer approximately 1/2". To get enough height to clear your crossmember you will likely need the Lift Kit # RR23QX. This will allow you to raise the suspension either 1-1/4" or 2-1/4" to clear your rear crossmember.
On a 4,000lb 25-1/4" Leaf Spring # e93SR the spring only has a height of 3". The 4,000lb 26" Leaf Spring # e48SR has a height of 4-1/4". So by going to the shorter spring you will most likely lose height depending on the height of your current springs.
Products Referenced in This Question
etrailer Rust-Resistant 4-Leaf Double Eye Spring for 4K Trailer Axles - 26" Long - Dacromet
- Trailer Leaf Springs
- Double Eye Springs
- 4000 lbs
- 1-3/4 Inch Wide
- 4 Leaf
- 26 Inch Long
- Dacromet
- etrailer
more information >
etrailer Rust-Resistant 3-Leaf Double Eye Spring for 4K Trailer Axles - 25-1/4" Long - Dacromet
- Trailer Leaf Springs
- Double Eye Springs
- 4000 lbs
- 1-3/4 Inch Wide
- 3 Leaf
- 25-1/4 Inch Long
- Dacromet
- etrailer
more information >
- Trailer Suspension Parts
- Shackle Links
- Camper
- Car Hauler
- Utility Trailer
- 2-1/4 Inch Long
- TruRyde
more information >
- Trailer Suspension Parts
- Shackle Links
- Camper
- Car Hauler
- Utility Trailer
- 3-1/8 Inch Long
- etrailer
more information >
- Trailer Suspension Parts
- Shackle Links
- Camper
- Car Hauler
- Utility Trailer
- 3-1/2 Inch Long
- TruRyde
more information >
Product Page this Question was Asked From
Correct Track Trailer Alignment and Lift Kit - Tandem Axle
- Trailer Suspension Parts
- Alignment and Lift Kits
- Boat Trailer
- Camper
- Car Hauler
- Snowmobile Trailer
- Utility Trailer
- Slipper Springs - 2 Inch
- Tandem Axle
- RV Ride Control
more information >
Featured Help Information
Instructions
Continue Researching
- Shop: CE Smith U-Bolt Kit for Mounting 5.2K to 7K, Round Trailer Axles - 7" Long U-Bolts - Zinc
- Q&A: Replacement Leaf Springs For a 2021 Dutchmen Coleman Light 2455BH Travel Trailer Camper
- Shop: CE Smith U-Bolt Kit for Mounting 3,500-lb, Round Trailer Axles - 5-1/2" Long U-Bolts - Zinc
- Shop: U-Bolt Kit for Mounting 3,500-lb, Round Trailer Axles - 5-1/2" Long U-Bolts
- Shop: Replacement U-Bolt with Nuts for 2-3/8" Round Trailer Axles - 1/2" Diameter - Zinc Plated
- Shop: etrailer Rust-Resistant 4-Leaf Double Eye Spring for 4K Trailer Axles - 26" Long - Dacromet
- Shop: Dexter Single Axle Heavy Duty Suspension Kit - Double Eye Springs
- Shop: Dexter Heavy Duty Suspension Upgrade Kit for Single Axle Trailers - Double Eye Springs
- Search Results: leaf spring
- Video: Bearing Repacking and Grease Seals Installation
- Search Results: leaf springs
- Search Results: 6 leaf spring
- Q&A: Replacement Bolt and Nut for MORryde Wet Bolt Kit part # MR46ZR
- Q&A: How to Measure Trailer Leaf Spring to Find Correct Replacement
- Search Results: idler hub
- Search Results: k71~359~00
- Video: CE Smith U-Bolt Kit for Round Trailer Axles Review
- Video: Review of etrailer Trailer Leaf Spring Suspension - 6 Leaf Double Eye Spring 5300 lbs Axle - e76SR
- Video: CE Smith Trailer Suspension - Leaf Spring Suspension - CE23002 Review
- Video: Review of etrailer 4 Leaf Double Eye Spring - e97SR
- Video: Dexter Heavy Duty Suspension Upgrade Kit Review
- Video: Review of etrailer Trailer Leaf Spring Suspension - 4-Leaf Double-Eye Spring for 4K Axles - e48SR
- Q&A: Shackle Suspension Kit for Single Axle Trailer With 3,500 lb Axle
- Q&A: Parts Needed to Upgrade from a 2-3/8 Inch Axle to a 3 Inch Axle
- Q&A: How to Determine Weight Capacity of Trailer Axle
- Search Results: shackle straps
- Q&A: Replacement Leaf Spring Options For a 2021 KZ Sportsman 301BHKSE
- Search Results: shackle kit
- Article: 5 Tell-Tale Signs It’s Time to Replace Your Trailer’s Leaf Springs
- Article: 4 Steps to Choosing Your 5th Wheel Pin Box