What Typically Causes Weak Trailer Brakes
Question:
Hi, I have adjusted the P3 all they up to max / 14 level but my trailer tires will still not lock up at all. They are activating because I can feel the trailer braking, it just doesnt seem to be coming anywhere near a lockup situation. The trailer is a PJ 16foot single axle tilt with no load on it when calibrating. Thank you
asked by: Tom G
Expert Reply:
Weak trailer brakes are typically caused by the brakes not being adjusted properly which you can check to see if they need to be adjusted tighter. You'd want to adjust them until there is a light drag on the wheel when turned by hand. Another possibility is that the brake output circuit is using too thin of wire which 10 gauge is the minimum for that like # 10-1-1. Or a grease seal could have blown and your drums now too slick to stop the trailer.
Products Referenced in This Question
Product Page this Question was Asked From
Tekonsha Prodigy P2 Trailer Brake Controller - 1 to 4 Axles - Proportional
- Trailer Brake Controller
- Proportional Controller
- Electric
- Electric over Hydraulic
- Automatic Leveling
- Under-Dash Box
- Dash Mount
- Up to 4 Axles
- LED Display
- Up to 360 Degrees
- Tekonsha
more information >
Featured Help Information
Instructions
Continue Researching
- Article: Brake Controller 7- and 4-Way Installation Kit (ETBC7)
- Article: Brake Controller Installation: Starting from Scratch
- Article: Towing a Trailer? Let's Talk About Brake Controllers
- Article: Trailer Wiring Diagrams
- Article: Wiring Trailer Lights with a 7-Way Plug (It's Easier Than You Think)
- Article: How to Install a Brake Controller on Chevrolet / GMC 1999-2006 Pickups
- Article: 5 Things to Know About Weight Distribution Hitches
- Q&A: What is the Difference Between a 4-Way and 7-Way Trailer Connector
- Q&A: Parts Needed To Install A Brake Controller On A 2023 Freightliner Cascadia
- Q&A: Brake Controller Recommendation for a Truck with Air Brakes and a Trailer with Electric Brakes
- Q&A: Parts Needed to Install 7-Way/4-Way on 2024 Kia Telluride with LED Taillights
- Q&A: How do I Tell if the Brake Controller is Bad
- Q&A: How Is Spring Bar Tension Set Up with Trailer Weight Distribution System
- Q&A: Lift Kit Options For A 2015 Winnebago Micro Minnie 1706FB