Parts Needed To Add 5-Way Connector To Power Lights For Headache Rack On 2020 Ram 3500
Question:
looking for a 5 wire harness for a headache rack on a 2020 ram 3500 8 bed.
asked by: Luis A
Expert Reply:
I have an option for you, but there is not a 5-way connector that is custom fit for your 2020 Ram 3500 and will allow to also hook up a trailer.
I recommend using the Hopkins Wiring Harness with 5-Pole Flat Trailer Connector - Vehicle End - 5' Long Item # HM37908, and if it is not long enough to reach from the back of your truck to the headache rack you can add Bonded 4 Wire # 16-4B-1 and Primary Wire # 16-1-1 which are sold by the foot, to give you extra length. If you need to extend the wires you will also need # DW05744-5 to make a secure connection.
You will then need 5 splice connectors # SWC502905-1 and a circuit tester like # PTW2993 to identify the functions of the wires of your factory harness that you need to splice into.
The 5-way connector will need to wired as followed:
Blue wire to vehicle reverse lights
Green wire to vehicle passenger turn signal
Yellow wire to vehicle driver turn signal
Brown wire to vehicle running lights
White wire to ground
To make the harness blend in a little better you can also add wire loom # 7509-10 to cover the wires, and use electrical tape # PP47FR to tape around the wire loom every few feet to make sure it doesn't open up.
I included a helpful article on trailer wiring for you to take a look at.
Products Referenced in This Question
Wire Loom 1/4" Diameter, 10' Long
- Wiring
- Wiring Protection
- Wire Loom
- 1/4 Inch Diameter
- Spectro
more information >
Deka Heat Shrink Butt Connector - 16-14 Gauge - Nylon Insulation - Blue - Qty 5
- Wiring
- Wire Connectors
- Butt Connectors
- 16-14 Gauge
- Deka
more information >
Electric Tape - PVC Insulating - Black - Qty 3
- Wiring
- Tools for Wiring
- Electrical Tools
- Electrical Tape
- Project Pro
more information >
Quick Splices - Self-Stripping Connector - Closed Port - 14-16-18 Gauge - Blue - Qty 1
- Wiring
- Wire Connectors
- Quick Splice Connectors
- 18-16-14 Gauge
- Spectro
more information >
Product Page this Question was Asked From
Hopkins Wiring Harness with 5-Pole Flat Trailer Connector - Vehicle End - 5' Long
- Trailer Wiring
- Trailer Connectors
- Vehicle End Connector
- 0 - 5 Feet Long
- Plug and Lead
- 5 Flat
- Hopkins
more information >
Continue Researching
- Article: Trailer Wiring Diagrams
- Q&A: Brake Controller Install Port Location on a 2015 Ford F-250 Super Duty
- Q&A: Do You Sell Replacement Bushings for the Leaf Springs on my Boat Trailer
- Q&A: How Does B&W Silencer Pad BWTS35020 Install
- Q&A: Converting A 6-Pole Trailer to 7-Pole Tow Vehicle Connection
- Q&A: Recommended Spare Tire Carrier for Utility Trailer with Angle Iron Frame
- Q&A: How Does Curt TriFlex NEXT Brake Controller Mount
- Q&A: Troubleshooting Trailer Connection Getting HOT
- Article: How to Measure for Trailer Hitch Drop
- Article: Performance Chips and Modules
- Article: Brake Controller Installation: Starting from Scratch
- Article: Wiring Trailer Lights with a 5-Way Plug (It's Easier Than You Think)
- Article: Can You Flat Tow a Ford Escape?
- Article: How to Raise Your Travel Trailer Height