Troubleshooting Short to Battery Message with Prodigy P3 Controller When it Rains
Question:
I have a Tekonsha P3 brake controller and the Curt wiring harness referenced here on a 2006 Dodge Ram 3500 diesel. Since the install of the second 7 way in the bed with the Curt harness I get a message on my brake controller that there is a short to the battery. This only happens when it is raining very hard while Im driving. It will do it even if there is no trailer attached. Suggestions where to start looking?
asked by: Todd P
Expert Reply:
Water is seeping into the new 7-way most likely and is causing a short between the 12 volt output circuit and the brake output circuit. The water is somehow getting introduced into the round connector behind the 7-way. It could also be at the 7-way at the rear of the vehicle too.
I'd recommend taking the connector apart to allow it to dry and then using dielectric grease like part # 11755 which will prevent the water from getting back in.
Product Page this Question was Asked From
Curt 5th Wheel/Gooseneck Custom Wiring Harness w/ 7-Pole Connector - 10' Long
- Custom Fit Vehicle Wiring
- Fifth Wheel and Gooseneck Wiring
- 10 Feet Long
- Custom Fit
- 7 Round - Blade
- CURT
more information >
Featured Help Information
Instructions
Continue Researching
- Q&A: 7-Way and Pigtail Wiring Harness Installation in 1995 Dodge Ram Pickup
- Article: Trailer Wiring Diagrams
- Q&A: What is Fifth Wheel Towing Capacity of 2006 Dodge Ram 2500 5.9 liter Cummins
- Q&A: Recommended Grease and Grease Gun To Use With Dexter EZ Lube Hubs On Travel Trailer Campers
- Q&A: Recommended 240v 50 Amp to 120v 30 Amp Adaptor
- Q&A: Replacement Air Conditioner Recommendations For A Dometic 600312.331 A/C
- Article: How (and Where) to Connect an RV Propane Grill
- Q&A: What is the Difference Between a Class II and a Class III Hitch?
- Article: Which Sway Control Hitch is Right For Your Trailer?
- Article: Ball Mount Basics: Weight Capacity, Class, and Size
- Article: Determining Trailer Tongue Weight
- Q&A: Why Does the Hopkins 5th Wheel Wiring Connector have 10 Pins but only 7 are Used
- Article: Wiring Trailer Lights with a 4-Way Plug (It's Easier Than You Think)
- Article: 5th Wheel Hitch Installation | The Ultimate DIY Guide