Troubleshooting Tekonsha Voyager Brake Controller When Green Light Stays On
Question:
i have a 2015 toyota tundra. recently installed tekonsha voyager and harness. controller worked great now the led stays green even when using the manual slide on the controller and does NOT activate trailer brakes. Any ideas??
asked by: Scott
Expert Reply:
There can be a couple of reasons why the light is staying green and why the brakes are not being applied. First, it could be because the power has been set at or near minimum.
If that is not the case the problem is more than likely an issue on the trailer. Unhook the trailer and use a 12V incandescent circuit tester. Check the Blue wire coming from the back of the brake controller. If you are showing power when the manual slide is moved, and the light on the brake controller turns Red, then the issue is on the trailer. Check the brake wires on the trailer and look for a short or broken wire and fix as needed.
Product Page this Question was Asked From
Tekonsha Voyager Trailer Brake Controller - 1 to 4 Axles - Proportional
- Trailer Brake Controller
- Proportional Controller
- Electric
- Manual Leveling
- Under-Dash Box
- Dash Mount
- Up to 4 Axles
- Indicator Lights
- Up to 90 Degrees
- Tekonsha
more information >
Featured Help Information
Instructions
Continue Researching
- Article: Trailer Wiring Diagrams
- Article: How to Choose the Right Trailer Hitch Class
- Q&A: Replacement Trailer Grease Seals for Allis 5013 29772
- Article: Brake Controller 7- and 4-Way Installation Kit (ETBC7)
- Q&A: Comparing the Curt Q20 and the Curt A20 5th Wheel Hitches.
- Q&A: Which Nev-R-Adjust Brake Assemblies for Load Trail 14K Dump Trailer
- Q&A: How To Add a Fuel Tank To a Truck with 5th Wheel Hitch In Bed
- Q&A: Wiring a Camper Shell Third Brake Light on a 2017 Chevrolet Silverado
- Q&A: Replacement LED Top Command Clearance Light With SAE-AP2-16 On Lens For 2018 Sunseeker Motorhome
- Article: Guide to Choosing the Best Truck for 5th-Wheel Towing
- Q&A: Kit to Convert 2021 Vanleigh Pinecrest 335RLP to Electric Over Hydraulic Disc Brakes
- Article: Best Camper Jacks
- Article: Brake Controller Installation: Starting from Scratch
- Article: Wiring Trailer Lights with a 4-Way Plug (It's Easier Than You Think)