Troubleshooting Green Light On Constantly on Voyager Brake Controller with No Trailer Connected
Question:
The green light on my controller is on all the time without a trailer hooked on.
asked by: Herbert M
Expert Reply:
When the green light on the Tekonsha Voyager Brake Activator, # 39510, remains constantly lit when the trailer is not connected it means that the brake controller is sensing a load on the blue brake output wire. This usually occurs when corrosion is present inside the trailer connector. You will need to check the pins as well as the wiring in the back of the plug for corrosion and dirt and clean it out.
A quick way to determine if the problem is with the wiring is to disconnect the blue wire from the back of the controller. If the green light goes out after the wire is disconnected then you know there is a problem along the blue wire somewhere between the controller and the 7-Way. If the light stays on then there is a problem with the internal circuitry of the brake controller and it will need to be replaced.
Product Page this Question was Asked From
Tekonsha Voyager Trailer Brake Controller - 1 to 4 Axles - Proportional
- Trailer Brake Controller
- Proportional Controller
- Electric
- Manual Leveling
- Under-Dash Box
- Dash Mount
- Up to 4 Axles
- Indicator Lights
- Up to 90 Degrees
- Tekonsha
more information >
Featured Help Information
Instructions
Miscellaneous Media
Continue Researching
- Article: Trailer Wiring Diagrams
- Article: How to Choose the Right Trailer Hitch Class
- Q&A: Replacement Trailer Grease Seals for Allis 5013 29772
- Article: Brake Controller 7- and 4-Way Installation Kit (ETBC7)
- Q&A: Comparing the Curt Q20 and the Curt A20 5th Wheel Hitches.
- Q&A: Which Nev-R-Adjust Brake Assemblies for Load Trail 14K Dump Trailer
- Q&A: How To Add a Fuel Tank To a Truck with 5th Wheel Hitch In Bed
- Q&A: Wiring a Camper Shell Third Brake Light on a 2017 Chevrolet Silverado
- Q&A: Replacement LED Top Command Clearance Light With SAE-AP2-16 On Lens For 2018 Sunseeker Motorhome
- Article: Guide to Choosing the Best Truck for 5th-Wheel Towing
- Q&A: Kit to Convert 2021 Vanleigh Pinecrest 335RLP to Electric Over Hydraulic Disc Brakes
- Article: Best Camper Jacks
- Article: Brake Controller Installation: Starting from Scratch
- Article: Wiring Trailer Lights with a 4-Way Plug (It's Easier Than You Think)