Troubleshooting Low Pressure With A Flow Max RV Fresh water Pump
Question:
We have checked connections, water in tank, cleaned the filter, no kinks in lines. However, the pump is hardly producing suction or output airflow. This is only the second season for the pump and it worked beautifully all last season. Any suggestions? Thank you.
asked by: Ed C
Expert Reply:
The first thing to always check is the power and ground when it comes to anything electronic. Double-check that you're actually getting a full 12 volts to the pump # LC689052 with a multimeter # PT89ZR. If not then the power source is the issue and can cause the the pump to partially work, like you've been experiencing.
When you winterized your trailer last fall did you run all of the water out of the line? This pump is safe to run dry so you could empty the tank and turn on the pump to ensure it pulls everything out of the line through a faucet. If not and you still had water inside the pump it could've froze and damaged the pump internally.
The only other thing you haven't checked that you could is simply the pressure adjuster screw on the end of the pump. There's a possibility that maybe someone messed with yours or that it somehow got turned down and needs to be adjusted to fix the pressure.
Products Referenced in This Question
Digital Multimeter with 42" Long Test Leads - LED Display
- Electrical Tools
- Testers
- Multimeter
- Yellow
- Performance Tool
more information >
Product Page this Question was Asked From
Flow Max RV Fresh Water Pump - 12 Volt - 3.0 Gallons Per Minute - 50 PSI
- RV Water Pump
- Diaphragm Pump
- 3.3 gpm
- 50 psi
- 140F
- 60C
- 12V
- Lippert
more information >
Featured Help Information
Instructions
Miscellaneous Media
Continue Researching
- Shop: Suspension Enhancement
- Shop: Timbren Rear Suspension Enhancement System
- Q&A: Troubleshooting Flow Max RV Water Pump that Won't Prime
- Shop: Furrion Indoor RV Soundbar - Surface Mount - 29-3/4" Wide x 3-7/8" Tall - 40 Watts - Black
- Shop: RV Bluetooth Portable Speaker - 2 USB Ports - 20W - Black
- Shop: Furrion RV Bluetooth Soundbar - 32" Wide x 4-7/8" Tall - 70.5 Watts - Black - Qty 1
- Q&A: 115 Volt AC V Fresh Water Pump to Replace Shurflo Water Pump
- Q&A: Troubleshooting Brake Controller with OL Code when Brakes are Applied
- Shop: Flow Max RV Fresh Water Pump - 12 Volt - 3.0 Gallons Per Minute - 50 PSI
- Video: Lippert Components RV Fresh Water - Water Pump - LC689054 Review
- Q&A: How To Tell If Bearing Buddy Has Enough Grease
- Q&A: Reset for Air Lift WirelessAIR Compressor System
- Q&A: How Much Grease is Needed in an EZ Lube Axle
- Q&A: The Remote Says Fail, Is There A Reset On The Air Lift WirelessAIR Compressor System
- Shop: Air Lift WirelessAIR Compressor System for Air Helper Springs - Remote - Bluetooth
- Shop: Furrion RV Power Cord Adapter - 30A Female to 20A Male - Black
- Article: 2 Steps for Hooking Up an External Propane Tank to Your RV
- Search Results: water pumps
- Search Results: 20 amp to 30 amp adapter
- Search Results: waste master
- Search Results: waste master
- Search Results: tork lift
- Search Results: lippert waste master
- Search Results: 103615
- Video: Bauer Products Propane Tank Lock Review
- Video: Lippert Components RV Sewer - Hose Hatch - LC362881 Review
- Video: Review of MB Sturgis Propane - Tees - 103615
- Article: Most Popular Wheel Bearings
- Video: Trailer Brake Controller Wire Testing
- Shop: Brake Controller