Butyl Tape To Seal Trailer Roof Panel Joint
Question:
Would this product be good to seal a joint on the roof of my 16 cargo trailer? I am replacing the galvanized steel panel roof with a continuous aluminum panel. There are two joints on the roof about 6 from each edge that has a side panel aluminum skin that comes up over the roof and then the roof panel overlays the side skin and is screwed down. The current seal is a liquid cured sealant like 344270341437-1 l which covers both the joint and the screw heads, but I am wondering if this butyl materiel would make a better seal. I have attached a couple of pictures which show the exiting roof panel and side transition.
asked by: Lorne C
Helpful Expert Reply:
The LaSalle Bristol XTRM Butyl Tape part # 344270341411-1 can definitely be used to seal the joint on the roof your cargo trailer. Butyl tape is used to seal off many roof accessories like trailer vents and fans. Since the butyl tape is pre-formed it is easier to install and get a water tight precise seal compared to some of the liquid sealants that can be more difficult to maneuver. The adhesive on the tape forms a bond with the surface that improves over time. This particular butyl tape is 1-1/2" so you do want to make sure it is wide enough to seal the joint but also cover the screw holes as well.
I also recommend to use Loctite threadlocker part # LT37420 when you replace the panel.
Products Referenced in This Question
Loctite Threadlocker 262 - High Strength - Up to 3/4" Nuts/Bolts - 0.20-Fl-Oz Tube
- Lubricants Sealants Adhesives
- Sealant
- Nut and Bolt Sealant
- 0.2 oz
- Loctite
more information >
Product Page this Question was Asked From
LaSalle Bristol Butyl Tape for XTRM RV roof membranes - 30' x 1-1/2" - Gray
- RV Roof Repair
- Tape
- Butyl Tape
- 45 Feet Long
- Gray
- LaSalle Bristol
more information >
Continue Researching
- Shop: Brake Controller
- Shop: RV Roof Membrane
- Shop: Alpha Systems QTDG Tape for RV Weatherproofing - 20' x 1" x 3/16" - Dark Gray
- Shop: LaSalle Bristol Butyl Tape for XTRM RV roof membranes - 30' x 3/4" - Gray
- Video: LaSalle Bristol XTRM Butyl Tape Review
- Video: Review of Alpha Systems RV Roof Repair - QTDG Watertight Adhesive Trim Tape - AL66FJ
- Shop: Alpha Systems 1021 Self-Leveling Sealant for RVs - White - 10.3 oz - Qty 1
- Shop: LaSalle Bristol XTRM PVC RV Roof Membrane - White - 40' x 9-1/2'
- Shop: LaSalle Bristol Butyl Tape for XTRM RV roof membranes - 30' x 1-1/2" - Gray
- Q&A: Stabilizer Jack Recommendation for 4 Corners of Hi-Lo Travel Trailer
- Search Results: rv windows
- Search Results: diesel heater
- Search Results: roof sealant
- Search Results: rv roof sealant
- Search Results: roof tape
- Search Results: windows
- Search Results: trailer window
- Shop: Tekonsha Prodigy P3 Trailer Brake Controller - 1 to 4 Axles - Proportional
- Shop: Tekonsha Primus IQ Trailer Brake Controller - 1 to 3 Axles - Proportional
- Shop: Vehicle Tow Bar Wiring
- Video: Hopkins Engager Push-To-Test Trailer Breakaway Kit Review
- Q&A: 2022 Toyota Highlander Wiring for a 7-Way Blade Connector
- Video: Choosing the Right Brake Controller
- Article: Trailer Wiring Diagrams
- Shop: Trailer Hitch
- Video: Choosing the Right Trailer Wiring
- Q&A: Recommended Replacement for Atwood Surge Brake Actuator 85778
- Shop: Trailer Wiring
- Article: Brake Controller 7- and 4-Way Installation Kit (ETBC7)
- Shop: Fifth Wheel Hitch