Replacement Leaf Spring Needed for 1999 Coachman Hunter Popup Camper
Question:
My 1999 Coachman Hunter 1060st popup broke its leaf spring. I’m having trouble finding a product that matches the current leaf spring. The spring is double eye, 4 leaf, 1.75” wide, spring height 2.5” installed on trailer, and 21.75” eye to eye installed on camper.. Is there an easier way to find a matching part?
asked by: Rolf J
Expert Reply:
The closest thing we have to what you described you have on your 1999 Coachmen Hunter Popup is the 3-Leaf Double-Eye Spring # e84SR. This measures 20-3/8" long center-eye to center-eye, is 1-3/4" wide, uses 3 leaves that are 1/4" thick each, and then the center of the eyes sit above the top of the spring right at 3-3/16".
This doesn't quite match up with your specs but we also take this measurement when there isn't a load on the leaf springs. If your measurements were taken without lifting the frame of your trailer (so the leaf spring isn't supporting anything) then that would explain the different in length and height. It's also worth noting that leaf springs will stretch over time which also would explain why your leaf spring is that much longer.
Please be sure to swap out both leaf springs at the same time on your camper so you get the best ride quality and your suspension setup is safe. Attached is a review video of this leaf spring for you to check out.
Product Page this Question was Asked From
3-Leaf Double-Eye Spring for 2,000-lb Trailer Axles - 20-3/8" Long
- Trailer Leaf Springs
- Double Eye Springs
- 2000 lbs
- 1-3/4 Inch Wide
- 3 Leaf
- 20-3/8 Inch Long
- Painted
- etrailer
more information >
Continue Researching
- Q&A: Trailer Hitch for a 2015 Honda Pilot
- Q&A: Parts Needed to Tow a Trailer with a 2015 Honda Pilot
- Q&A: Installation of Hitch on Fifth Wheel Trailer
- Q&A: When Flat Towing a Vehicle How Much Tongue Weight is on the Trailer Hitch
- Q&A: Troubleshooting A Clunking Noise Between A Fifth Wheel Hitch And Base Rails While Towing
- Q&A: Replacement Parts for Fan-Tastic Vent 8000 Series
- Article: Wiring Trailer Lights with a 7-Way Plug (It's Easier Than You Think)
- Q&A: Recommended RV Exterior Ladder for 22 Ft Thor Four Winds RV
- Article: Brake Controller 7- and 4-Way Installation Kit (ETBC7)
- Article: How to Accurately Measure Trailer Leaf Springs
- Article: 5 Tell-Tale Signs It’s Time to Replace Your Trailer’s Leaf Springs
- Article: Breakaway Kit Installation for Single and Dual Brake Axle Trailers
- Article: Double-Eye Trailer Suspension System Review
- Article: Where to Position the Trailer Axle?