Upgrading Wet Bolts and Shackle Straps for a Suretrac 16 Foot Utility Trailer
Question:
I have a newer suretrac 16 utility trailer that since almost new has had squeaky and creaky suspension since a few months old. I’m assuming the nylon bushings are shot so I have been looking into upgrading to the wet bolt kit. The trailer also has an issue with the eye of the leaf spring front and rear of equalizer making contact with frame of trailer over bumps and bridge interchanges…trailer is level, never once overloaded, only utilizing roughly 4,300lbs equipment + trailer weight of 7k capacity. This has been an issue since day 1 with northern ohio road conditions. There is only 1” or so of clearance between both leaf spring eyes and frame when trailer is loaded and level. It has 3 1/4” center of eye to center of eye shackles, in theory i would think shorter shackles would slightly raise the ride high but ultimately should solve this low clearance issue with no negative drawbacks. Is this correct? What size would you recommend? I was looking at the 2 1/4” wet bolt kit
asked by: Kyle
Expert Reply:
It sounds like your shackles are too long or you have the wrong size equalizer. I do think replacing your current shackles would be the best solution. I recommend the MORryde Suspension Upgrade Kit for Tandem Axle Trailers - 2-1/4" Long Shackle Straps item # MR46ZR. These wet bolts and bronze bushings help keep your setup lubricated.
Products Referenced in This Question
MORryde Suspension Upgrade Kit for Tandem Axle Trailers - 2-1/4" Long Shackle Straps
- Trailer Suspension Parts
- Suspension Kits
- Boat Trailer
- Snowmobile Trailer
- 2-1/4 Inch Long
- Tandem Axle
- MORryde
more information >
Product Page this Question was Asked From
Replacement Shackle Strap - 2-5/8" Long
- Trailer Suspension Parts
- Shackle Links
- Boat Trailer
- Camper
- Car Hauler
- Snowmobile Trailer
- Utility Trailer
- 2-5/8 Inch Long
- etrailer
more information >
Continue Researching
- Shop: MORryde Suspension Upgrade Kit for Tandem Axle Trailers - 2-1/4" Long Shackle Straps
- Shop: Lippert Smart Jack Electric Trailer Jack w/ Footplate - A-Frame - 22-1/2" Lift - 3.5K - Black
- Shop: Dexter Heavy-Duty Suspension Kit for Tandem-Axle Trailers - 1-3/4" Wide Double Eye Springs
- Q&A: How to Read the Lippert Components Axle Description Measurements
- Q&A: Replacement Kwikee Electric Steps for a 2005 Jayco Greyhawk 31SS
- Q&A: Trailer Tire Wear on Right Side, Outside Tread Only and Trailer Pulls Hard to One Side
- Q&A: Lowering Height at Front of Fifth Wheel Trailer By Adjusting Pin Box
- Q&A: Best Track System for a Roof Rack on a NuCamp T@G Camper
- Q&A: Replacement 5 Leaf Slipper Spring for a Tandem Axle Dump Trailer with Two 6K Axles
- Article: Trailer Wiring Diagrams
- Q&A: Determining Replacement Hub And Bearings For Dexter P-12 SLR Trailer Axle
- Article: Rooftop Cargo Carriers
- Article: How Long Can You Boondock in an RV?
- Article: Brake Controller 7- and 4-Way Installation Kit (ETBC7)
- Article: RV and Camper Types, RV Classes
- Article: Choosing the Right Suspension Kit for Your Truck and Trailer
- Article: Stability Control for Heavy Duty Vehicles