Recommended 4-Way Flat Trailer Connector with Pigtail
Question:
I have a flat four plug that has six wires coming out of it. Two white, two brown, a green, and a yellow. I need to splice a new plug onto the current set up because a section of the wiring is frayed by the trailer tongue. What type of harness should I get and which wires do I need to connect to the new flat four plug? Thanks!
asked by: Jared M
Expert Reply:
I recommend using one of the Hopkins Easy-Pull 4-Way Flat harnesses. These have a connector with a loop in the middle that makes disconnecting your trailer wiring from your tow vehicle much easier than a standard 4-Way Flat connector. The wiring is also labeled which helps with the installation.
This comes in a 12" version as part # HM48114 and a 48" version as part # HM38134. We also have the 12" part # HM48138 which has an integrated LED tester.
I recommend using 16 Gauge Butt Connectors # DW05744-5 and then combining the 2 white wires for the ground and the 2 brown wires for your running/tail lights.
Products Referenced in This Question
Deka Heat Shrink Butt Connector - 16-14 Gauge - Nylon Insulation - Blue - Qty 5
- Wiring
- Wire Connectors
- Butt Connectors
- 16-14 Gauge
- Deka
more information >
Hopkins Endurance Easy-Pull Harness w/ 4-Pole Flat Connector - Trailer End - Jacketed - 48"
- Trailer Wiring
- Trailer Connectors
- Trailer End Connector
- 0 - 5 Feet Long
- Plug and Lead
- 4 Flat
- Hopkins
more information >
Hopkins Endurance Easy-Pull Harness with 4-Pole Flat Connector - LED Tester - Trailer End - 12"
- Trailer Wiring
- Trailer Connectors
- Trailer End Connector
- 0 - 5 Feet Long
- Plug and Lead
- 4 Flat
- Hopkins
more information >
Product Page this Question was Asked From
Hopkins Endurance Easy-Pull Harness with 4-Pole Flat Trailer Connector - Trailer End - 12" Long
- Trailer Wiring
- Trailer Connectors
- Trailer End Connector
- 0 - 5 Feet Long
- Plug and Lead
- 4 Flat
- Hopkins
more information >
Featured Help Information
Miscellaneous Media
Continue Researching
- Q&A: Using XTRM Universal Sealant to Replace Existing Original XTRM Caulk on Roof
- Article: How to Rent an RV
- Article: What Exactly is Tongue Weight?
- Q&A: Replacement Microwave for Highpoint # EC942K9
- Q&A: Replacement Electric Brakes for Dexter PR-FF SEC-FF 5.2KPR-GGSEC-GG 12X2XQ 36-89
- Q&A: Equalizer Replacement Options for Dexter 13-122 Equalizer
- Article: How to Charge RV Batteries
- Q&A: What Hitch Gives the Highest Ground Clearance on My 2022 Toyota Sienna?
- Q&A: Can 12 Volt Battery Replace Two 6 Volt Batteries
- Q&A: Is a Master Key Needed to Install or Remove a Thule Lock Cylinder
- Article: Brake Controller Installation: Starting from Scratch
- Article: Trailer Wiring Diagrams
- Article: How to Measure for Travel Trailer and Fifth Wheel Steps
- Article: Adapters for Towing a 5th Wheel Trailer with a Gooseneck Hitch