Troubleshooting An Atwood G6A6 RV Water Heater
Question:
Hi there, I am having trouble keeping my hot water heater on in my 1992 Terry Resort 19E trailer. The heater is an Atwood G6A6. Pilot light stays on but I cant get the heater on and when I do, it stays on for 5-10 minutes and then turns off. Serial number - 96202183207 6 gallon 8800 BTU Can you tell me what tank to get to replace this please? Of if there is a part that will fix this without replacing the whole tank. THanks so much!
asked by: Jess
Expert Reply:
Unfortunately Atwood has gone out of business and all of their replacement parts are secondhand at this point so you'd be looking at replacement of the entire unit. To me it sounds like an issue with the T-Stat since it is heating and then shutting off. You could try looking around but you might end up getting priced gouged for a simple parts since there aren't many available.
If you instead have to replace the entire unit then I recommend going with the Furrion RV Tankless Water Heater # FR48SR. Newer units like this one are all a bit smaller at 12-5/8" wide x 12-5/8" tall so you'll have to frame the new unit in a bit. It doesn't have to be fancy and you can use the plywood to fill in the gaps since it will all be covered by the access door. You'll want to use butyl tape # AL28FJ on both the unit and access door mounting flanges as well as non-sag sealant # 344270341437-1 on the outer edge of the access door for a waterproof seal.
It is quite a bit of money to replace the whole unit versus just replacing a part, but the performance upgrade and lower maintenance requirements of the Furrion Tankless Water Heater will be worth it. These units have a 13,000 to 60,000 BTU rating, whereas the G6A6 only has an 8,8000 BTU rating. With no tank you won't have to complete as much maintenance or be as limited when it comes to gallons of hot water produced. These units offer up to 144 gallons of on-demand hot water per hour.
Products Referenced in This Question
LaSalle Bristol XTRM Universal Non-Sag Sealant for RVs - White - 10.1 oz - Qty 1
- RV Roof Repair
- Sealant
- 10.1 oz
- Non-Sag
- Self-Leveling
- White
- LaSalle Bristol
more information >
Alpha Systems Butyl Tape for RV Weatherproofing - 20' x 1" x 3/16"
- RV Roof Repair
- Tape
- Butyl Tape
- 20 Feet Long
- Colors May Vary
- Alpha Systems
more information >
Furrion RV Tankless Water Heater - Gas - Automatic Pilot - 60,000 BTU - 16" x 18" Door
- RV Water Heater
- Tankless Water Heater
- Gas
- 60000 Btu
- 12 Volts
- Auto Pilot
- 12-5/8L x 12-13/16W x 19-3/16D Inch
- Furrion
more information >
Product Page this Question was Asked From
Furrion RV Tankless Water Heater - Gas - Automatic Pilot - 60,000 BTU - 16" x 16" Door
- RV Water Heater
- Tankless Water Heater
- Gas
- 60000 Btu
- 12 Volts
- Auto Pilot
- 12-5/8L x 12-13/16W x 19-3/16D Inch
- Furrion
more information >
Featured Help Information
Instructions
Miscellaneous Media
Continue Researching
- Q&A: Replacement Water Heater for an Atwood G6A6 6 Gallon Water Heater
- Shop: LaSalle Bristol Utopia RV Bathroom Faucet w/ D-Spud - Dual Knob Handle - Ivory
- Shop: LaSalle Bristol Utopia RV Bathroom Faucet w/ D-Spud - Dual Knob Handle - Chrome
- Shop: Furrion RV Tankless Water Heater - Gas - Automatic Pilot - 60,000 BTU - 18" x 18" Door
- Q&A: Recommended Replacement For Atwood Water Heater G6A3
- Shop: Dometic RV Water Heater - Gas and Electric - Automatic Pilot - 120 Volt - 10,000 Btu - 6 Gal Tank
- Search Results: water heater tank
- Search Results: 44649
- Q&A: Trailer Grease Seal to Replace 127194TB
- Shop: Grease Seals 10-36 (pair)
- Article: Trailer Wiring Diagrams
- Shop: Trailer Hitch
- Shop: Tekonsha Prodigy P3 Trailer Brake Controller - 1 to 4 Axles - Proportional
- Search Results: 68149
- Shop: Trailer Wiring
- Article: Brake Controller 7- and 4-Way Installation Kit (ETBC7)
- Q&A: Recommended Replacement Grease Seal for 2014 Shorelander Boat Trailer
- Q&A: Wiring a Camper Shell Third Brake Light on a 2017 Chevrolet Silverado
- Search Results: 25580
- Shop: Fifth Wheel Hitch
- Shop: Hub Bearing Kit for Lippert, Dexter, and AL-KO Axles - 3,500 lb with #84 Spindle
- Video: Choosing the Right Brake Controller
- Article: How to Choose the Right Trailer Hitch Class
- Video: Roadmaster Automatic Battery Disconnect Installation - 2020 GMC Sierra 1500
- Shop: Brake Controller
- Q&A: 05680-C Master Cylinder Replacement for Trailer Recommendation
- Search Results: dust cap
- Article: Trailer Maintenance Schedule
- Search Results: tang washer
- Video: Brake Buddy Classic 3 Portable Supplemental Braking System Installation - 2009 Jeep Wrangler Unlimit