Routing Brake Controller Install Harness on 2020 Ford Explorer Under Dash
Question:
Mike L provided this answer in part: If your 2020 Explorer is equipped with the factory 7-way trailer connector, it will be have the brake controller connector under the dash. The connector is located under the dash, above and to the right of where the drivers right knee would be. The connector will be rectangular, and will be gray in color. If you use a Tekonsha brake controller like the Tekonsha Primus, part # TK90160, the # 3035-P wiring adapter is the correct harness. My follow up question is: Im assuming this will require the installer to remove the plastic piece that is in front of the drivers knees the connector should be obviously visible at this point. What are your recommendations for hiding the wiring harness, any photos would be beneficial. Thanks.
asked by: John
Expert Reply:
If you watch the attached install video for the brake controller install harness part # 3035-P at the 9:45 mark you can see how we took the interior apart on a similar Ford Explorer to route the wiring as well as access the connector you need to use.
Products Referenced in This Question
Tekonsha Plug-In Wiring Adapter for Electric Brake Controllers - Ford, Lincoln, Mercury
- Accessories and Parts
- Trailer Brake Controller
- Wiring Adapter
- Plugs into Brake Controller
- Vehicle Specific
- Tekonsha
more information >
Tekonsha Primus IQ Trailer Brake Controller - 1 to 3 Axles - Proportional
- Trailer Brake Controller
- Proportional Controller
- Electric
- Automatic Leveling
- Under-Dash Box
- Dash Mount
- Up to 3 Axles
- LED Display
- Up to 90 Degrees
- Tekonsha
more information >
Product Page this Question was Asked From
Tekonsha Plug-In Wiring Adapter for Electric Brake Controllers - Ford, Lincoln, Mercury
- Accessories and Parts
- Trailer Brake Controller
- Wiring Adapter
- Plugs into Brake Controller
- Vehicle Specific
- Tekonsha
more information >
Featured Help Information
Instructions
Continue Researching
- Article: Brake Controller Installation on a Ford Full-Size Van
- Article: Trailer Wiring Diagrams
- Article: Brake Controller 7- and 4-Way Installation Kit (ETBC7)
- Article: Wiring Trailer Lights with a 7-Way Plug (It's Easier Than You Think)
- Article: Towing a Trailer? Let's Talk About Brake Controllers
- Q&A: Recommended Replacement Brakes for a 2007 Pace Trailer w/ 15 Inch Rims
- Article: Brake Controller Installation: Starting from Scratch
- Article: Breakaway Kit Installation for Single and Dual Brake Axle Trailers
- Q&A: Bulldog Powered-Drive Kit Compatibility With 12K Ram Landing Gear
- Q&A: Best Brake Controller for a 2014 Fleetwood Bounder Motorhome
- Q&A: Location of Brake Controller Wiring Connector on 2014 Fleetwood Bounder on Ford F-53 Chassis
- Q&A: Brake Controller Recommendation for a 2021 Ford F-53 with Brake Controller Harness
- Q&A: Can Trailer Brakes Be Manually Applied with Tow-Pro RED24FR Liberty Brake Controller
- Q&A: Replacement AC Unit for Dometic Duo-Therm Air Conditioner 630516.331 on 2008 Four Wind Siesta