Lubricating Demco Hijacker Autoslide 5th Wheel Hitch
Question:
Are there any parts of the demco sliding hitch that should be lubricated either with oil or Grease?
asked by: Scott D
Expert Reply:
The Demco Hijacker Autoslide 5th Wheel Trailer Hitch # DM8550034 comes pre-greased from the factory but Demco does recommend keeping all moving parts well greased and lubricated over time as part of regular maintenance.
They recommend simply applying WD40 or similar lubricant into the locking bar tube, opening and closing the locking bar a few times for even application. The jaw pins can be removed and greased by unhooking the jaw spring and snap rings. Routinely clean and inspect the pins for any wear and apply a light coat of grease before re-installing them.
Once a month or every 5,000 miles also inspect the lower guide plates and roller (on the sliding base) for excessive wear and apply a multi purpose or lithium grease to the side guide plates.
I have attached the complete installation and operating instructions manual below that you can also look through.
Product Page this Question was Asked From
Demco Autoslide 5th Wheel Trailer Hitch w/ Slider - Single Jaw - Above Bed - 18,000 lbs
- Fifth Wheel Hitch
- Sliding Fifth Wheel
- Above Bed Rails
- 4500 lbs Vertical Load
- 18000 lbs GTW
- Double Pivot
- Premium - Single-Hook Jaw
- 16-1/2 - 19-1/4 Inch Tall
- 14 Inch Fore/Aft Travel
- Demco
more information >
Featured Help Information
Instructions
Miscellaneous Media
Continue Researching
- Shop: Fifth Wheel Hitch
- Shop: Demco Autoslide 5th Wheel Trailer Hitch w/ Slider - Single Jaw - Above Bed - 13,000 lbs
- Shop: Demco Autoslide 5th Wheel Trailer Hitch w/ Slider - Single Jaw - Above Bed - 18,000 lbs
- Video: Review of Demco RV Fifth Wheel Hitch - Replacement Adapter Plates - DM99GV
- Search Results: dm99gv
- Shop: Replacement Side Plates for Demco Autoslide 5th Wheel Trailer Hitch - Ram
- Q&A: Where to Lubricate Demco Hijacker Autoslide Fifth Wheel Hitch
- Shop: Suspension Enhancement
- Shop: Demco Autoslide 5th Wheel Hitch w/ Slider - Single Jaw - Ram Prep Package - 18K
- Shop: Trailair Air Ride 5th Wheel Pin Box - Lippert 1116 - 21,000 lbs
- Shop: Mighty Cord RV Extension Cord - 50 Amp - 25'
- Video: Review of Demco Replacement Urethane Bumper 5th Wheel Hitch - DM15469
- Video: SumoSprings Solo Rear Helper Springs Installation - 2022 Chevrolet Silverado 1500
- Video: Timbren Rear Suspension Enhancement Installation - 2022 Chevrolet Silverado 1500
- Shop: Timbren Suspension Enhancement System - Rear Axle
- Video: Manufacturer Review - Demco Autoslide 5th Wheel Trailer Hitch
- Search Results: road active
- Video: Best 2022 GMC Sierra 2500 Vehicle Suspension Options
- Search Results: roadactive suspension
- Q&A: Will the RoadActive Leaf Spring Kit # RAS3611-CHD Provide Support with a 3,400 Vertical Weight?
- Shop: Trailer Wiring
- Q&A: Troubleshooting Auto Level Fail Error on Lippert Ground Control System
- Video: Choosing the Best Fifth Wheel Hitch
- Q&A: Recommended Maintenance of Demco Hijacker Autoslide
- Search Results: dm8550037
- Q&A: Should Demco Autoslide 5th Wheel Hitch Head Manually Turn Without Trailer Connected?
- Q&A: Too Much Slop When Starting and Stopping with Demco Autoslide 5th Wheel Trailer Hitch
- Q&A: Can the Head on the Demco Hijacker Be Moved Manually
- Shop: RV Roof Membrane
- Shop: Floor Mats